Scholarly article on topic 'In-situ restoration of one-stage partial nitritation-anammox process deteriorated by nitrate build-up via elevated substrate levels'

In-situ restoration of one-stage partial nitritation-anammox process deteriorated by nitrate build-up via elevated substrate levels Academic research paper on "Earth and related environmental sciences"

Share paper
Academic journal
Sci. Rep.

Academic research paper on topic "In-situ restoration of one-stage partial nitritation-anammox process deteriorated by nitrate build-up via elevated substrate levels"


Received: 08 July 2016 Accepted: 27 October 2016 Published: 24 November 2016

In-situ restoration of one-stage partial nitritation-anammox process deteriorated by nitrate build-up via elevated substrate levels

Xiaolong Wang & Dawen Gao

The one-stage partial nitritation and anammox process (PN/A) has been a promising microbial process to remove ammonia from wastewater especially with low carbon/nitrogen ratio. The main breakdown was the deterioration caused by overgrowth of nitrite oxidizing bacteria (NOB) resulting effluent nitrate build-up in the PN/A process. This study presented an in-situ restoring strategy for suppressing NOB activity in a one-stage granular PN/A system deteriorated over 2 months, using elevated concentrations of substrates (ammonia and nitrite) under limited dissolved oxygen level. The results showed that the NOB activity was successfully suppressed after 56 days of restoration, and finally the ratio of produced nitrate/consumed ammonium was reduced from 36.8% to 7%. On day 66 the nitrogen removal rate obtained as 1.2 kg N/(m3-d). The high FA level (5-40 mg/L) and low dissolved oxygen (<0.13 mg/L) were responsible for NOB suppression. From quantitative PCR (qPCR) analysis, after this restoration, anammox bacteria had a widely growth, and AOB stay stable, but Nitrospira increase and Nitrobacter declined. High amount of NOB was still persistent in the granules, which was not easy to wash-out and threaten the deammonification performance.

The increasing demands of nitrogen discharge limit from wastewater with minimized energy consumption has always been a great challenge for wastewater treatment. As a novel nitrogen removal pathway discovered in early 1990s, anaerobic ammonium oxidation (anammox) is the process in which anammox bacteria use ammonium as electron donor, and nitrite as electron acceptor, to generate dinitrogen gas under anaerobic condition1. So anammox must be applied coupling with partial nitritation (PN/A) in different styles to treat ammonia wastewater with low carbon/nitrogen ratio in one-stage or two-stage2. The PN/A process is catalyzed by aerobic ammonia oxidizing bacteria (AOB) and anammox bacteria, respectively (as formula 1). Although two-stage PN/A process obtains higher efficiency, one-stage PN/A is considered as more economical3'4. Compared to traditional nitrification-denitrification treatment, one-stage PN/A is also a more cost-effective and energy efficient process5,6.


0. 43N + 0.11NO-

There are two main challenges to obtain a stable performance in PN/A process. One inherent challenge is the slow growth of anammox bacteria (doubling time of 8.3-11 days)7,8. So the long biomass retention is an basic demand to prevent biomass washout from reactor. One way is using biofilm or granule system9, like moving bed reactor10,11 or fixed bed reactor12. In suspended growth system, external settling time or device is also possible to prevent biomass loss in the outflow13. Because AOB has shorter doubling time (7-8 h) than anammox bacteria, AOB is able to be retained along with anammox bacteria14-16. The other main obstacle is the stable performance of partial nitritation, in other words, is the enriching of AOB and meanwhile suppressing nitrite oxidizing bacteria (NOB). It was evident that the limit step in PN/A process was the partial nitritation17,18. Although with similar ecology habits, these two kinds of bacteria can be distinguished by slightly different growth rates under particular environment conditions. It is almost consensus that high temperature (over 25 °C)19, low dissolved oxygen

State Key Laboratory of Urban Water Resource and Environment, Harbin Institute of Technology, Harbin 150090, China. Correspondence and requests for materials should be addressed to D.G. (email:

Figure 1. The performance of nitrogen removal in restoration process.

(DO, below about 1-2 mg/L)20,21, intermittent aeration with interval above 15 min22, all benefit to enrich AOB. The inhibitors such as free ammonia (FA) and free nitrous acid (FNA) also have advantages on suppress NOB for its low toleration23.

To date, at least 100 full-scale PN/A installations have been operated worldwide24. Even so, out of control of NOB resulting nitrate build-up in the effluent remained one of the major issues in the full-scale installations25. Some full-scale PN/A system faced the problem of above 30% of nitrate build-up in effluent26. Considering the scarcity of massive anammox biomass for reinoculation, restoration study for the deteriorated PN/A processes is needed. Some inhibitors had been tested in the in-situ restoration of nitrate build-up in one-stage PN/A process, such as hydrazine, hydroxylamine, organic matter, ultrasonic treatment or aeration patterns. Hydrazine is the intermedium of anammox process. Long-term addition of 4 mg/L hydrazine had strong inhibition effect on NOB, meanwhile, the effect of promoting anammox bacteria growth and partially inhibiting AOB also improved the nitrogen removal efficiency of PN/A process27. Hydroxylamine is also an intermedium of AOB and anammox bacteria, so it can promote both of them. Although the single suppressing of 20 mg/L hydroxylamine on NOB was reversible, combining with SRT control of 40 days, NOB was successfully suppressed in one-stage PN/A process28. Organic matter could suppress NOB growth and promote anammox growth at the same time, and to same certain extent, reduce effluent nitrate production by introduction of denitrification29,30. It was also reported 0.09 kJ/mg VSS of ultrasonic treatment benefited to enhance the AOB and depress NOB activity31. A certain anoxic period was able to slow down NOB metabolism, so intermittent aeration with long enough anoxic period (>15-20 min) and aerobic periods (not exceed the specific lag phase of NOB) was sufficient for suppressing NOB, which had

been applied in full-scale plant22,32,33.

The purpose of this study was to restore a deteriorated lab-scale granular PN/A system suffered nitrate build-up by inhibiting NOB activity under gradually elevated concentration of ammonia and nitrite under limited DO level. The restoration stage was evaluated by stoichiometry ratios of typical PN/A process, and the main inhibition factors associated was discussed. The 16S copy numbers of functional microorganism (anammox bacteria, AOB and NOB) in the restoration stages were also determined. At last, the possibility to treat the NOB overgrowth in deterioration PN/A system was concluded.


Performance in restoration stages. The one-stage granular PN/A reactor was operated at 32 °C, 7.7 of pH, DO lower than 1.3 mg/L with intermitted aeration, and was fed with influent with 84 mg/L NH4+-N at the beginning. At the beginning of the experiment, the PN/A system suffered high nitrate production for at last two months, with the initial loading rate was about 2 kg N/(m3-d). The performance of different stages of deterioration, restoration and deammonification in terms of ammonium, nitrite and nitrate is shown in Fig. 1. From the performance of deterioration before the restoration process, about 17 mg/L nitrate in effluent (>30% of the removed ammonia) caused the two ratios of ATN/AAmmonia and ANitrate/AAmmonia deviated from theoretical value (Fig. 2).

The restoration process (day 10-66) contained three stages as variations of substrate concentrations (Fig. 1). From day 10-28, the system was feed with substances with gradually increasing concentrations. Starting from day 10, nitrite was introduced to this system to expect to improve the deammonification performance. The concentration of NO2--N was gradually increased according to its removal efficiency in effluent (>95%). At the same time, doubled the concentration of NH4+-N to maintain external ammonium for deammonification simultaneously. Considering above 400 mg/L of influent nitrite and ammonia nitrogen was a danger level to anammox bacteria


= ANitrate/Ammonia


Time (d)


- Stagel i Staged ■ i 7 \/\ ita ■ in\ i \ mm 1 Stage m j i i

0 86 1 \ / 1 1 1 1 1 1 1 1 1 i i i i i i i

%.ll 1 1 1 1 1 1 1 1 1 1 1 1

i I 1 I i 1 I T»

Figure 2. The ratio variations of one-stage PN/A system in restoration stages. Value 0.11 and 0.86 were the theoretical stoichiometric ratios of ANitrate/AAmmonia and ATN/AAmmonia, respectively.

from operation experiences in our lab, ammonium concentration began to synchronize to that of nitrite from day 23-33. From day 28-34 the system entered the stable stage with the highest substrate concentrations. The concentrations of NO2--N and NH4+-N were stabilized at around 420 mg/L for one week. High substance concentrations were expected to stable the suppressing effect on NOB. From day 34-66, the substance concentrations were falling down. In this period, the introduced nitrite would be removed and this system was transformed to run as the way of deammonification gradually. At day 34, NO2--N concentration halved with unchanged NH4+-N concentration, and then after one week, no NO2--N supplied and NH4+-N concentration halved. The system obtained the volumetric loading of nitrogen removal of 1.2 kg N/(m3-d) at last.

Variations of stoichiometric ratios in PN/A process. In a theoretical PN/A process without influence of NOB, denitrifying bacteria or dissimilatory nitrate reduction to ammonium process, the nitrate production and total nitrogen removal are only conducted by anammox process, so two theoretical ratio existed: total nitrogen removal to ammonium nitrogen removal (ATN/AAmmonia) of 0.86 and nitrate production to ammonium nitrogen removal (ANitrate/AAmmonia) of 0.11 (as formula 1). So these two ratios of ATN/AAmmonia and ANitrate/AAmmonia are the indicated parameters to estimate the stability and efficient of deammonification process. If external nitrite was oxidized to nitrate by NOB, nitrate would be excessively produced, which then led to ANitrate/AAmmonia more than 0.11. On the other hand, if denitrifying bacteria existed in PN/A system, total nitrogen would be excessively removed, which then led to ATN/AAmmonia more than 0.86. So a well performed PN/A process relied on the well cooperation of AOB and anammox communities.

Then the restoration process was evaluated from this two ratios variations (Fig. 2). The theoretical ratios of ATN/AAmmonia and ANitrate/AAmmonia in anammox process (2.00 and 0.26, respectively) are different from those in PN/A process34. As influent nitrite was introduced from day 10, ATN/AAmmonia went up rapidly and fluctuated between 1.2 and 2. Nitrite introduction meant a promotion of anammox process, so both ratios should increase in this system theoretically. The down trend of ANitrate/AAmmonia was clear during day 9 to day 50, which indicated the gradually suppressing of NOB activity. After day 50 when this system was totally run as a deammonification way, the sudden absence of influent nitrite caused a short deteriorated performance (day 50-54), and then the system adapted and achieved ratios of ATN/AAmmonia and ANitrate/AAmmonia close to 0.80 and 0.11 in average.

Quantification of functional bacteria. Quantification of the microorganisms in every stages was performed by quantitative PCR (qPCR) (Fig. 3). After the additional nitrite was introduced, anammox bacteria had a widely growth, with 16S gene increased from 3.98 x 105 copies/mg to 1.43 x 107 copies/mg. Considering the highest nitrogen removal rate (NRR) had reached as high as about 20 kg N/(m3-d) on stage II, the anammox bacteria were well protected in the anaerobic compartments of the granular sludge, even under limited aeration environment. The 16S gene copies of AOB was still maintained in the same order of magnitude.

At the stage one when high substrates were introduced, 16S gene copy numbers of Nitrobacter declined from 4.52 x 107 copies/mg to 2.17 x 106 copies/mg, and then maintained in the same order of magnitude after the condition of no nitrite addition and ammonium decreasing. But the copy numbers of Nitrospira increased before Stage II from 2.63 x 106 copies/mg to 1.06 x 108 copies/mg, and then maintained in the same order of magnitude till Stage III.

Figure 3. Absolute quantification of functional bacteria.


Effect of dissolved oxygen. The one-stage PN/A process has been achieved successfully through different kinks of control strategies. The key is regulating the synergistic relationships between AOB and anammox bacteria, and suppressing NOB growth at the same time. DO concentration is one of the most important parameters in operating PN/A process26. The strategy of low DO combined with nitrite introduction, could stimulate the anammox activity that assisted to suppress NOB through competing nitrite35. Anammox bacteria is able to compete nitrite with NOB, so it is effective to keep low level of redundant nitrite in the reactor to limit electronic acceptors for NOB26. Although the oxygen affinity for AOB (0.04-0.4 mg/L) and for NOB (0.5-1.5 mg/L) variated in different researches, AOB owned the higher oxygen affinity than NOB in the same single habitat in most cases36,37. By the way, there were also several reports which indicated NOB had higher oxygen affinity than AOB38-40. This affinity difference gave AOB the chance to selectively grow up under limited oxygen condition. In one-stage PN/A process, DO levels that AOB preferred were inconsistent with different biomass community, sludge types and reactor configurations, and variated from 0.1 mg/L to about 2 mg/L as below. In granule sludge or membrane bioreactor, DO is able to penetrate into a certain depth of sludge or biofilm to keep aerobic zone for AOB, at the same time, the inside core zone was anaerobic for anammox bacteria growth, so the size of granular sludge and the appropriate DO concentration were often associated to keep the synergistic relationships between AOB and anammox bacteria. To set up DO concentration at 0.6-0.8 mg/L and granule diameter at 2-5 mm, the nitrogen removal efficiency was achieved 81% in an upflow membrane-aerated biofilm reactor20. Smaller granule with 3 mm diameter under DO less than 0.5 mg/L also showed the nitrogen removal efficiency of 88%9. As to suspended DEMON deammonification system using almost flocculate sludge, DO was strictly control at 0-0.25 mg/L by rapid impulse intermittent aeration41. But the single limitation of oxygen supply may be not enough to suppress NOB growth, just as the case in full-scale DEMON plant in Plettenberg32. Long operation under DO below 2 mg/L did not solve the nitrate build-up (as the day1-10) in this study as well. It was also reported that the intermittent aeration pattern was more effective to inhibit NOB activity, compared to continuous aeration pattern, without affecting ammonia removal at the same time42. In order to suppress NOB activity, we used 1.3 mm diameter of granule, and kept DO level as low as 0.13 mg/L by intermittent aeration. This DO was a very low DO level compared to most studies, which would maintain a favorable environment to suppressing NOB activity.

Effect of FA and FNA. High concentration of ammonia or nitrite could inhibit activity of AOB and NOB, in which FA-N and FNA-N are well known as direct inhibitors43. Luckily, AOB was able to tolerate about tenfold higher concentration of those two kinds of substrates than NOB. As for FA-N, about 0.1-3 mg/L was most efficient in inhibiting NOB23,44,45. There were 5-40 mg/L of FA-N in influent and not more than 5 mg/L in effluent, both of which would obviously inhibited NOB activity (Fig. 4). As for FNA-N, about 0.02 mg/L was able to inhibited NOB seriously23,46. Low level of FNA-N existed in influent (<8 ^g/L) and effluent (< 1 ^g/L) because of high pH, so there should be a low inhibition effects on NOB. FA-N and FNA-N also had inhibition effect on anammox bacteria. The inhibiting concentration of FA-N and FNA-N to anammox bacteria were above 50 mg/L and 5 |ig/L, respectively47. So those substrate levels had little influent on activity of AOB or anammox bacteria. So the inhibition from FA-N combined with limited DO level would be the main factors to inhibit NOB activity20.

NOB was always more sensitive to FNA than FA. It was reported that FNA also had a strong biocidal effect on NOB at ppm (mg/L) levels20, but this biocidal effect was almost ignorable in our study. And this FNA level need high concentration of nitrite and relative low pH level. Most one-stage PN/A systems were with high ammonia level and relative high pH level, so FA would become an important inhibitor to NOB activity in many stud-ies30,44,48. This was also the reason why NOB was easily suppressed in PN/A process with high influent ammonium (more than 280 mg/L) even under relatively high DO levels or low temperatures9,29. But 10 mg/L or 23 mg/L FA

Figure 4. FA-N and FNA-N variations in restoration stages.

unexpectedly failed to suppress NOB growth26,49. For the application of treating low ammonia wastewater, such as municipal wastewater (50-70 mg/L ammonia), the inhibition of FA or FNA on NOB would be tiny. The inhibition of FA also variated along with the biomass morphologies. Compared to flocs, granules have more stronger tolerance to higher FA-N levels such as 5-10 mg/L50. It was also reported that the inhibitory threshold of the FA on the PN/A process could reach as high as 77 mg/L51. Although FA is the promising inhibited factor to NOB growth, in a particular habit the working inhibition level of FA would adjust according to the actual conditions.

Evolution of functional bacteria. Nitrospira and Nitrobacter were two common NOBs existed in waste-water treatment plant, but were unwelcome in PN/A process. In many PN/A systems treating wastewater with high ammonium concentration, it seems that the abundance and activity of NOB can be totally suppressed to undetectable level from the beginning of start-up stage in long-term operation29,30,52. These two nOb species were detected at a large copies numbers in this reactor. So this was the reason why the nitrate build-up appeared.

It was reported that Nitrospira-like NOB behaved as K-strategists with high substrate affinity to adapt to low nitrite and oxygen concentrations. On the contrary, Nitrobactor-like NOB behaved as r-strategists with low substrate affinity to adapt to high nitrite and oxygen concentrations. So Nitrospira often out-completed Nitrobactor under limited DO in deammonification reactors10. In this research, with the introduced rising nitrite concentration, Nitrobacter was inhibited to a certain extent, but Nitrospira increased. The phenomenon was consistent with other studies30.

After the restoration, even though the gene copy numbers of NOB were still high, the two ratios of ATN/A Ammonia and ANitrate/AAmmonia were close to their theoretical values. This suggested that abundant NOB existed but with low activity in the reactor. The inconformity between abundance and activity was also reported in other studies. The AOB abundant did not correlate with the nitritation performance in full-scale petroleum refinery wastewater treatment plant53. As the operation temperature decrease, the copies numbers of NOB was stable at around 40 copies/ng DNA while its activity increased from undetectable to significant, which seemed that NOB could hide its activity under inhabitation situations54.

It seemed that NOB were persistent in the sludge and could not be easily washed out, especially after NOB community had built up to a certain percentage55. In the intermittent aerated-EGSB, NOB in floc sludge was easily washed out for its low settleability. Selective wash-out protocol of NOB by a short SRT has proved to be effective in suspended and completely mixed PN/A system, but was unuseful in biofilm or granule sludge system like in this study. In this study, the floc sludge harbored high abundant AOB (4.72 x 109 copies/mg) than the granular sludge, while NOB had same order of magnitude in floc and granular sludge. Therefore, the undesirable NOB was persistent in granules.

Regardless, the high NOB abundant is always a penitential threat to the PN/A process. Sometime NOB activity may increase again after changing operation pattern even under low NOB abundant56. If NOB contamination was serious, the problem of nitrate build-up could be simply solved only by discarding the sludge with more NOB and reinoculation, if enough seeding sludge with anammox bacteria was available conveniently26. The nitrate build-up also reappeared after reinoculation32. So the best way to suppress NOB is to optimize the operation conditions for dominating AOB in the system at the beginning of the start-up stage to compete NOB growth, and to utilize the multiple inhibitors discussed above will be a promising way. At the stage III, Nitrobacter-like or Nitrospira-like NOB almost maintained stable which indicated the failed wash-out NOB from granular sludge system, but only with the successful suppress of the NOB activity30.

Several NOB inhibitors were already tested in restoration of PN/A system, such as hydrazine, hydroxylamine and organic matter as mentioned in the introduction part. Hydrazine and hydroxylamine are highly toxic intermedia to human, animals, plants or bacteria at low levels, and NaNO2 is obviously much safer and more economical to add into the wastewater treatment plant57,58. As to organic matter, simultaneous partial nitrification,

9 } 10


Figure 5. The schematic of the intermittent aerated EGSB system. 1 The EGSB body; 2 Sample ports; 3 Microporous diffusers; 4 Recirculation; 5 Warm water circulation; 6 Heater; 7 Warm water tank; 8 Temperature controller; 9 DO Probe; 10 ORP probe; 11 Aerator; 12 Peristaltic pump.

anaerobic ammonium oxidation and denitrification (SNAD) was already successfully developed in many studies59,60. PN/A process could be also restored by introduction of additional denitrification pathway. But the influent C/N ratio highly affected the SNAD performance, and the autotrophic anammox also easily inhibited by the organic matter61. The restoration is more like an emergency processing, not a common operation strategy. And the combination of several inhibition methods and control strategies is recommended.

In conclusion, the deteriorated one-stage PN/A system with nitrate build-up was successfully restored, and the NOB activity was suppressed using elevated substrates level (up to 420 mg/L) under limited DO level (<0.13 mg/L). High FA concentration and low DO took responsibility for this successful restoration. In the restoration stages, anammox bacteria and Nitrospira-like NOB had a big growth, while AOB almost stayed stable, while Nitrobacter-like NOB decreased. Although the activity of NOB was suppressed of successfully after the restoration, high gene copy numbers of NOB still existed in the system, which was difficult to wash-out without manual sludge discharge.


Reactor configuration and operation. A lab-scale EGSB (expanded granular sludge bed) was modified with a set of aeration equipment to culture AOB-anammox granule, which just called intermittent aerated EGSB (Fig. 5). This reactor had a working volume of 0.5 L (height of 0.4 m, diameter of 4 cm), and a total capacity of 1.3 L, which was made of polymethyl methacrylate. A water jacket was used to maintain a suitable temperature of 32 °C. Blackout fabric was covered to avoid light inhibition. The aeration rate was adjusted by gas flowmeter along the monitoring data of DO level. Aeration pump was turned on every 3 min and then hold for 30 s controlled by the time relay. The supernatant above the triphase separator was recirculated at about 300 mL/min resulting an upflow velocity of about 16 m/h. The pH was kept on 7.7 in reactor via addition KHCO3 in influent, and the measured ORP varied from 60 to120 mV in this reactor.

Inoculation and operation. The reactor was inoculated with nitrifying sludge (130 mL) and anammox granular sludge (100 mL), which came from storage floc nitritation sludge and a lab-scale EGSB culturing anammox granule, respectively. But most of the flocs were washed out gradually in the later operation stages. Almost only granular sludge was selectively retained and the MLVSS (Mixed Liquor Volatile Suspended Solids) was 280 g/L. The ammonium, nitrite and inorganic carbon in the synthetic wastewater were supplied in the forms of ammonium sulfate, sodium nitrite and potassium bicarbonate, respectively. Trace element solution and vitamin solution were prepared according to previous formulation (Table S1). By excess aeration, the phenomenon of nitrate build-up in effluent appeared, which caused the bad nitrogen removal performance.

Primer Sequence (5' to 3') Length Annealing Temperature Target

Eub341F cctacgggaggcagcag 17 58.9 Eubacteria

Eub534R attaCCgCggCtgCtggC 18

AMX-808F arcygtaaacgatgggcactaa 22 55.7 Anammox bacteria

AMX-1040R cagccatgcaacacctgtrata 22

CTO189F ggagvaaagyaggggatcg 19 55.5 Nitrosospira sp. Nitrosomonas sp.

CTO654R ctagcyttgtagtttcaaacgc 22

Nitro-1198F acccctagcaaatctcaaaaaaccg 25 59.2 Nitrobacter sp.

Nitro-1423R cttcaccccagtcgctgacc 20

NSR 1113F cctgctttcagttgctaccg 20 56.8 Nitrospira sp.

NSR1264R gtttgcag^attgtacxg 20

Table 1. Prime pairs used in this study.

The restoration process was implemented as below. Under limited oxygen condition (<0.13 mg/L), added external nitrite into the influent and elevated concentrations of both ammonia and nitrite (<420 mg/L) to introduce the substance inhibition to NOB. After high substance concentrations inhibition (420 mg/L), substance concentrations reduced to the original levels and then examined the autotrophic nitrogen removal performance after restoration process.

Analytical methods. The concentrations of ammonium (NH4+), nitrite (NO2--N) and nitrate (NO3--N) were measured according to the standard methods by a spectrophotometer (T6-1650F, Persee, Beijing, China)62. DO, ORP and pH were measured and recorded as the manufacturer's instructions (Multi 3430, WTW, Munich, Germany). Concentration of FA and FNA was calculated as reported, in which the temperature value was taken as 32 °C, and the pH value was taken as 7.9 and 7.7 in influent and effluent, respectively63.

DNA extraction and quantification. Equal granular biomass from different sample ports were mixed and harvested on day 9, 33 and 60, and then stored immediately at -20 °C after washed by PBS buffer solution. Genome DNA was extracted from samples with particular dry weight using FastDNA SPIN Kit (MP Biomedicals, CA, USA) and evaluated by spectroscopic methods. Primer pairs of Eub 341F/534R, AMX 808F/1040R, CTO 189F/654R, Nitro 1198F/1423R and NSR 1113F/11264R were amplified to produce the standard for qPCR. The detailed information of every used prime pair listed below (Table 1). The PCR mixture and program was set as the manual of Taq polymerase (Taq HIFI, Transgen, beijin, China) on thermal cyclers (T-Gradient Trio PCR, Biometra, Germany). The PCR products were electrophoresed with 1.5% agarose gel on electrophoresis system.

Every successful PCR product was directly ligated into a pUCm-T vector and transformed into DH5a chemically competent cells using pUCm-T Vector Cloning Kit (Sangon Biotech, Shanghai, China). The white colonies including the inserts were pick out and the plasmids were extracted with Easy PureTM Plasmid MiniPrep Kit (Transgen, beijin, China) and then accurately evaluated by NanoDrop 8000 spectrophotometer (NanoDrop 2000, Thermo Fisher Scientific, MA, USA) as the standard substances for absolute quantification of qPCR.

The copy numbers of the 16S rDNA genes of total bacteria, anammox bacteria, AOB and NOB were determined with absolute quantitative PCR (qPCR) using SGExcel FastSYBR Mixture (With ROX) Kit (Sangong Biotech, Shanghai, China). To construct standard curves for every primer pair, every quantified recombinant plasmid mentioned above was serially diluted in 10-fold steps as standard template. For all qPCR amplifications, a 25 |iL reaction containing 12.5 uL of FastSYBR Mixture, 0.5 uL of each primer, 1 |iL template DNA, 10.5 |iL ddH2O was used. Each reaction performed in triplicate. The qPCR protocol was as follows: 94 °C for 20s, 40 cycles of 94 °C for 30s, annealing for 45s and extension at 72 °C for 45s, followed by a melting curve step for the examining specificity of the amplification. The cycle thresholds were determined automatically by SDS software of ABI 7500 Real-Time PCR System (Applied Biosystems, CA). Relative copy numbers among target organism were calculated by excel software.


1. Van de Graaf, A. A. et al. Anaerobic oxidation of ammonium is a biologically mediated process. Appl. Environ. Microbiol. 61, 1246-1251 (1995).

2. Zhang, Z. & Liu, S. Hot topics and application trends of the anammox biotechnology: a review by bibliometric analysis. SpringerPlus 3, 220 (2014).

3. Wett, B. et al. Going for mainstream deammonification from bench-to full-scale for maximized resource efficiency. Water Sci. Technol. 68, 283-289 (2013).

4. Bagchi, S., Biswas, R. & Nandy, T. Autotrophic Ammonia Removal Processes: Ecology to Technology. Crit. Rev. Env. Sci. Technol. 42, 1353-1418 (2012).

5. Vlaeminck, S. E., De Clippeleir, H. & Verstraete, W. Microbial resource management of one-stage partial nitritation/anammox. Microb. Biotechnol. 5, 433-448 (2012).

6. Sliekers, A. O., Third, K., Abma, W., Kuenen, J. & Jetten, M. CANON and Anammox in a gas-lift reactor. FEMS Microbiol. Lett. 218, 339-344 (2003).

7. van der Star, W. R. et al. The membrane bioreactor: a novel tool to grow anammox bacteria as free cells. Biotechnol. Bioeng. 101, 286-294 (2008).

8. Isaka, K., Date, Y., Sumino, T., Yoshie, S. & Tsuneda, S. Growth characteristic of anaerobic ammonium-oxidizing bacteria in an anaerobic biological filtrated reactor. Appl. Microbiol. Biotechnol. 70, 47-52 (2006).

9. Li, X. & Sung, S. Development of the combined nitritation-anammox process in an upflow anaerobic sludge blanket (UASB) reactor with anammox granules. Chem. Eng. J. 281, 837-843 (2015).

10. Persson, F. et al. Structure and composition of biofilm communities in a moving bed biofilm reactor for nitritation-anammox at low temperatures. Bioresour. Technol. 154, 267-273 (2014).

11. Rosenwinkel, K. H. & Cornelius, A. Deammonification in the Moving-Bed Process for the Treatment of Wastewater with High Ammonia Content. Chem. Eng. Technol. 28, 49-52 (2005).

12. Zhang, L., Zhang, S., Peng, Y., Han, X. & Gan, Y. Nitrogen removal performance and microbial distribution in pilot- and full-scale integrated fixed-biofilm activated sludge reactors based on nitritation-anammox process. Bioresour. Technol. 196, 448-453 (2015).

13. Wett, B., Nyhuis, G., Takács, I. & Murthy, S. Development of enhanced deammonification selector. WEFTEC 2010, 5917-5926 (2010).

14. Bock, E., Koops, H.-P. & Harms, H. Cell biology of nitrifying bacteria in Special Publications of the Society for General Microbiology (ed. J. I. Prosser) 17-38 (IRL Press, 1986).

15. Peng, Y. & Zhu, G. Biological nitrogen removal with nitrification and denitrification via nitrite pathway. Appl. Microbiol. Biotechnol.

73, 15-26 (2006).

16. Philips, S., Laanbroek, H. J. & Verstraete, W. Origin, causes and effects of increased nitrite concentrations in aquatic environments. Rev. Environ. Sci. Biotechnol. 1, 115-141 (2002).

17. Furukawa, K., Lieu, P. K., Tokitoh, H. & Fujii, T. Development of single-stage nitrogen removal using anammox and partial nitritation (SNAP) and its treatment performances. Water Sci. Technol. 53, 83-90 (2006).

18. Szatkowska, B., Cema, G., Plaza, E., Trela, J. & Hultman, B. A one-stage system with partial nitritation and Anammox processes in the moving-bed biofilm reactor. Water Sci. Technol. 55, 19-26 (2007).

19. Van Kempen, R., Mulder, J., Uijterlinde, C. & Loosdrecht, M. Overview: full scale experience of the SHARON® process for treatment of rejection water of digested sludge dewatering. Water Sci. Technol. 44, 145-152 (2001).

20. Wang, D. et al. Achieving Stable Nitritation for Mainstream Deammonification by Combining Free Nitrous Acid-Based Sludge Treatment and Oxygen Limitation. Scientific Reports 6, 25547 (2016).

21. Fitzgerald, C. M., Camejo, P., Oshlag, J. Z. & Noguera, D. R. Ammonia-oxidizing microbial communities in reactors with efficient nitrification at low-dissolved oxygen. Water Res. 70, 38-51 (2015).

22. Gilbert, E. M. et al. Response of Different Nitrospira Species To Anoxic Periods Depends on Operational DO. Environ. Sci. Technol. 48, 2934-2941 (2014).

23. Vadivelu, V. M., Keller, J. & Yuan, Z. Free ammonia and free nitrous acid inhibition on the anabolic and catabolic processes of Nitrosomonas and Nitrobacter. Water Sci Technol 56, 89-97 (2007).

24. Lackner, S. et al. Full-scale partial nitritation/anammox experiences-An application survey. Water Res. 55, 292-303 (2014).

25. Ma, B. et al. Biological nitrogen removal from sewage via anammox: Recent advances. Bioresour. Technol. 200, 981-990 (2016).

26. Joss, A. et al. Combined nitritation-anammox: advances in understanding process stability. Environ. Sci. Technol. 45, 9735-9742 (2011).

27. Xiao, P., Lu, P., Zhang, D., Han, X. & Yang, Q. Effect of trace hydrazine addition on the functional bacterial community of a sequencing batch reactor performing completely autotrophic nitrogen removal over nitrite. Bioresour. Technol. 175, 216-223 (2015).

28. Wang, Y., Wang, Y., Wei, Y. & Chen, M. In-situ restoring nitrogen removal for the combined partial nitritation-anammox process deteriorated by nitrate build-up. Biochem. Eng. J. 98, 127-136 (2015).

29. Huang, X. et al. One-stage partial nitritation and anammox in membrane bioreactor. Environ. Sci. Pollut. Res. 23, 1-14 (2016).

30. Liang, Y. et al. Stability and nitrite-oxidizing bacteria community structure in different high-rate CANON reactors. Bioresour. Technol. 175, 189-194 (2015).

31. Zheng, M. et al. Ultrasonic Treatment Enhanced Ammonia-Oxidizing Bacterial (AOB) Activity for Nitritation Process. Environ. Sci.

Technol. 50, 864-871 (2016).

32. Jardin, N. & Hennerkes, J. Full-scale experience with the deammonification process to treat high strength sludge water-a case study. Water Sci. Technol. 65, 447-455 (2012).

33. Kornaros, M., Dokianakis, S. N. & Lyberatos, G. Partial Nitrification/Denitrification can be attributed to the slow response of Nitrite Oxidizing Bacteria to periodic anoxic disturbances. Environ. Sci. Technol. 44, 7245-7253 (2010).

34. Kuenen, J. G. Anammox bacteria: from discovery to application. Nat. Rev. Microbiol. 6, 320-326 (2008).

35. Pérez, J., Lotti, T., Kleerebezem, R., Picioreanu, C. & van Loosdrecht, M. C. M. Outcompeting nitrite-oxidizing bacteria in singlestage nitrogen removal in sewage treatment plants: A model-based study. Water Res. 66, 208-218 (2014).

36. Ma, Y., Peng, Y., Wang, S., Yuan, Z. & Wang, X. Achieving nitrogen removal via nitrite in a pilot-scale continuous pre-denitrification plant. Water Res. 43, 563-572 (2009).

37. Blackburne, R., Yuan, Z. & Keller, J. Partial nitrification to nitrite using low dissolved oxygen concentration as the main selection factor. Biodegradation 19, 303-312 (2008).

38. Malovanyy, A., Trela, J. & Plaza, E. Mainstream wastewater treatment in integrated fixed film activated sludge (IFAS) reactor by partial nitritation/anammox process. Bioresour. Technol. 198, 478-487 (2015).

39. Regmi, P. et al. Control of aeration, aerobic SRT and COD input for mainstream nitritation/denitritation. Water Res. 57, 162-171 (2014).

40. Wu, J., Yan, G., Zhou, G. & Xu, T. New insights in partial nitrification start-up revealed by a model based approach. RSC Adv. 5,

100299-100308 (2015).

41. Wett, B. et al. Key parameters for control of DEMON deammonification process. Water Practice 1, 1-11 (2007).

42. Sobotka, D., Czerwionka, K. & Makinia, J. The effects of different aeration modes on ammonia removal from sludge digester liquors in the nitritation-anammox process. Water Sci. Technol. 71, 986-995 (2015).

43. Vadivelu, V. M., Keller, J. & Yuan, Z. Free ammonia and free nitrous acid inhibition on the anabolic and catabolic processes of Nitrosomonas and Nitrobacter. Water Sci. Technol. 56, 89-97 (2007).

44. Vlaeminck, S. E. et al. Nitrogen Removal from Digested Black Water by One-Stage Partial Nitritation and Anammox. Environ. Sci. Technol. 43, 5035-5041 (2009).

45. Vadivelu, V. M., Keller, J. & Yuan, Z. Effect of free ammonia on the respiration and growth processes of an enriched Nitrobacter culture. Water Res. 41, 826-834 (2007).

46. Vadivelu, V. M., Yuan, Z., Fux, C. & Keller, J. The Inhibitory Effects of Free Nitrous Acid on the Energy Generation and Growth Processes of an Enriched Nitrobacter Culture. Environ. Sci. Technol. 40, 4442-4448 (2006).

47. Jin, R., Yang, G., Yu, J. & Zheng, P. The inhibition of the Anammox process: A review. Chem. Eng. J. 197, 67-79 (2012).

48. Qiao, S. et al. High-rate nitrogen removal from livestock manure digester liquor by combined partial nitritation-anammox process. Biodegradation 21, 11-20 (2009).

49. Jaroszynski, L., Cicek, N., Sparling, R. & Oleszkiewicz, J. Importance of the operating pH in maintaining the stability of anoxic ammonium oxidation (anammox) activity in moving bed biofilm reactors. Bioresour. Technol. 102, 7051-7056 (2011).

50. Vazquez-Padin, J. R. et al. Autotrophic nitrogen removal at low temperature. Water Sci. Technol. 63, 1282-1288 (2011).

51. Yang, Y. et al. Determine the operational boundary of a pilot-scale single-stage partial nitritation/anammox system with granular sludge. Water Sci. Technol. 73, 2085-2092 (2016).

52. Hu, Z. et al. Nitrogen Removal by a Nitritation-Anammox Bioreactor at Low Temperature. Appl. Environ. Microbiol. 79, 2807-2812 (2013).

53. Figuerola, E. L. M. & Erijman, L. Diversity of nitrifying bacteria in a full-scale petroleum refinery wastewater treatment plant experiencing unstable nitrification. J. Hazard. Mater. 181, 281-288 (2010).

54. De Clippeleir, H. et al. One-stage partial nitritation/anammox at 15 °C on pretreated sewage: feasibility demonstration at lab-scale. Appl. Microbiol. Biotechnol. 97, 10199-10210 (2013).

55. Ma, Y., Sundar, S., Park, H. & Chandran, K. The effect of inorganic carbon on microbial interactions in a biofilm nitritation-anammox process. Water Res. 70, 246-254 (2015).

56. Kanders, L. et al. Impact of seeding on the start-up of one-stage deammonification MBBRs. Environ. Technol. 35, 2767-2773 (2014).

57. Smith, R. P. & Layne, W. R. A comparison of the lethal effects of nitrite and hydroxylamine in the mouse. J. Pharmacol. Exp. Ther. 165, 30-35 (1969).

58. Guldberg Kleno, T. et al. Mechanisms of hydrazine toxicity in rat liver investigated by proteomics and multivariate data analysis. Proteomics 4, 868-880 (2004).

59. Chen, H., Liu, S., Yang, F., Xue, Y. & Wang, T. The development of simultaneous partial nitrification, ANAMMOX and denitrification (SNAD) process in a single reactor for nitrogen removal. Bioresour. Technol. 100, 1548-1554 (2009).

60. Wang, C.-C. et al. Simultaneous partial nitrification, anaerobic ammonium oxidation and denitrification (SNAD) in a full-scale landfill-leachate treatment plant. J. Hazard. Mater. 175, 622-628 (2010).

61. Zhi, W. & Ji, G. Quantitative response relationships between nitrogen transformation rates and nitrogen functional genes in a tidal flow constructed wetland under C/N ratio constraints. Water Res. 64, 32-41 (2014).

62. Apha, A. Standard methods for the examination of water and wastewater. (American Public Health Association, Washington, DC, 1998).

63. Anthonisen, A., Loehr, R., Prakasam, T. & Srinath, E. Inhibition of nitrification by ammonia and nitrous acid. J. WaterPollut. Control Fed. 48, 835-852 (1976).


This work was supported by Natural Science Foundation of Heilongjiang Province (No. ZD201412) and Major Science and Technology Program for Water Pollution Control and Management (2013ZX07201007-001).

Author Contributions

X.W. and D.G. conceived and designed the study. X.W. performed the experiments and all authors analyzed the data, and discussed the results. X.W. and D.G. wrote the manuscript text. All authors reviewed the manuscript.

Additional Information

Supplementary information accompanies this paper at Competing financial interests: The authors declare no competing financial interests.

How to cite this article: Wang, X. and Gao, D. In-situ restoration of one-stage partial nitritation-anammox process deteriorated by nitrate build-up via elevated substrate levels. Sci. Rep. 6, 37500; doi: 10.1038/srep37500 (2016).

Publisher's note: Springer Nature remains neutral with regard to jurisdictional claims in published maps and institutional affiliations.

l/gN (J) I This work is licensed under a Creative Commons Attribution 4.0 International License. The images Ib^^ki^M or other third party material in this article are included in the article's Creative Commons license, unless indicated otherwise in the credit line; if the material is not included under the Creative Commons license, users will need to obtain permission from the license holder to reproduce the material. To view a copy of this license, visit

© The Author(s) 2016