Scholarly article on topic 'Use of non-growing Lactococcus lactis cell suspensions for production of volatile metabolites with direct relevance for flavour formation during dairy fermentations'

Use of non-growing Lactococcus lactis cell suspensions for production of volatile metabolites with direct relevance for flavour formation during dairy fermentations Academic research paper on "Veterinary science"

Share paper
Academic journal
Microb Cell Fact
OECD Field of science

Academic research paper on topic "Use of non-growing Lactococcus lactis cell suspensions for production of volatile metabolites with direct relevance for flavour formation during dairy fermentations"


Use of non-growing Lactococcus lactis cell suspensions for production of volatile metabolites with direct relevance for flavour formation during dairy fermentations

Background: Lactococcus lactis is a lactic acid bacterium that has been used for centuries in the production of a variety of cheeses, as these bacteria rapidly acidify milk and greatly contribute to the flavour of the fermentation end-products. After a short growth phase during cheese ripening L. lactis enters an extended non-growing state whilst still strongly contributing to amino acid-derived flavour formation. Here, a research approach is presented that allows investigation of strain- and amino acid-specific flavour formation during the non-growing state.

Results: Non-growing cells of five selected L. lactis strains were demonstrated to degrade amino acids into flavour compounds that are relevant in food fermentations and differs greatly from production of flavour compounds using growing cells. As observed earlier in other research set-ups and with other microorganisms, addition of NADH, a-ketoglutarate and pyridoxal-5-phosphate was demonstrated to be essential for optimal flavour formation, suggesting that intracellular pools of these substrates are too low for the significant production of the flavour compounds. Production of flavours during the non-growing phase strongly depends on the individual amino acids that were supplied, on the presence of other amino acids (mixtures versus single compounds), and on the strain used. Moreover, we observed that the plasmid-free model strains L. lactis MG1363 and IL1403 produce relatively low amounts of flavour components under the various conditions tested.

Conclusions: By using this simplified and rapid approach to study flavour formation by non-growing lactic acid bacteria, lengthy ripening periods are no longer required to assess the capacity of strains to produce flavours in the long, non-growing state of dairy fermentation. In addition, this method also provides insight into the conversion of single amino acids versus the conversion of a mixture of amino acids as produced during protein degradation. The generated results are complementary to earlier generated datasets using growing cells, allowing assessment of the full flavour forming potential of strains used as starter cultures in industrial food fermentation processes.

Keywords: Flavour, Lactococcus lactis, Lactic acid bacteria, Non-growing, Amino acid metabolism, Screening method, Cheese

* Correspondence:

'University of Amsterdam, Swammerdam Institute of Life Sciences, Science

park 904, PO Box 94216, 1090, GE Amsterdam, The Netherlands

Full list of author information is available at the end of the article

Bert van de Bunt1,2, Peter A Bron1,2,3, Lolke Sijtsma1,3,4, Willem M de Vos5,6 and Jeroen Hugenholtz'


Bio Med Central

© 2014 van de Bunt et al.; licensee BioMed Central Ltd. This is an Open Access article distributed under the terms of the Creative Commons Attribution License (, which permits unrestricted use, distribution, and reproduction in any medium, provided the original work is properly credited. The Creative Commons Public Domain Dedication waiver ( applies to the data made available in this article, unless otherwise stated.


Fermented dairy products contain a wide range of flavours resulting from biochemical conversions of milk ingredients such as caseins, milk fat and lactose. Particularly in cheese, the lactic acid bacterium Lactococcus lactis contributes significantly to the degradation of casein and many cheese flavours are formed as a result of these proteolytic processes and, more specifically, the conversion of amino acids [1-3]. L. lactis can import small peptides derived from this extracellular proteolysis. Intracellular peptidases convert these small peptides into amino acids which are subsequently converted to flavour compounds [4-7]. Many of the observed differences in the flavour of various cheese types are related to the presence of different (combinations of) L. lactis strains [8-11]. During cheese ripening, cells reach a non-growing state after a couple of days while they continue to produce flavour compounds [12,13]. The time needed and the process towards the non-growing state are strain-specific and have been shown to affect the flavour formation [14]. During cheese ripening, a multitude of flavours are formed via various conversion routes and the process of flavour formation is, generally, slow. Therefore, monitoring this process is quite labour-intensive. Although it is clear that specific L. lactis strains possess different flavour-producing activities [15], the exact biochemical explanation for the differences is not fully understood. This is mainly due to the fact that many of the relevant microbial pathways have not yet been characterized or have not been studied under the relevant, non-growing conditions found in cheese. Due to the long time periods required for cheese ripening it is not feasible to distinguish which observed conversions are purely chemical or are directly related to the presence of microbial enzymes. In addition, in actual cheese the formation of compounds can only be followed cumulatively from beginning to the end of the ripening period and direct extraction of active microorganisms or microbial enzymes from cheese has proven to be quite difficult if not impossible [16,17]. For this reason, various approaches, often with different objectives, have been designed to study cheese flavour development. These include measuring flavour-profiles of cheeses in time by using Gas Chromatography in combination with Mass Spectrometry (GCMS) [18-20]. In specific cases, this method is preceded by steam distillation [21,22]. However, sampling during ripening is tedious and time-consuming. The so called CH-easy model was developed where concentrated cells of lactic acid bacteria were added to a young industrial cheese, in which the endogenous bacteria have been inactivated [23]. This system has been applied in various studies that allowed simultaneous analysis of multiple strains of lactic acid bacteria. Measurements in cheese and cheese-paste give insight into the complete mix of flavours that can be produced by certain lactic acid

bacteria but it will not allow the investigation of specific enzyme and substrate reactions, in relation to specific flavour production. For this reason many specific enzyme activities obtained from lactic acid bacteria growing in cheese were studied, such as proteinase and peptidase activities [24-28]. In addition, individual enzymes involved in amino acid catabolism such as transferases, decarboxy-lases and dehydrogenases have been intensively studied [24,29-32]. These enzyme activities can be measured in cell free extracts [29,33], whereas in the case of the cell wall proteinase, enzyme activity can be measured in whole cells [25,34]. The combination of nuclear magnetic resonance and GC is an elegant way to study amino acid catab-olism [29] but is limited to the analysis of labelled compounds. Flavour formation by cheese starter bacteria could also be studied during the first 24 h of a milk fermentation process, until the cells reach the stationary phase of growth, but this approach will exclude all flavour formation in the subsequent non-growing phase, which is the physiological state of the starter bacteria during most of the ripening period. Mass spectrometry metabolic fingerprinting is reported to be a comprehensive and sensitive approach to study flavour formation in a model cheese made with ultra-filtrated milk concentrate [35]. For all these models it can be argued that the experimental set-up does not represent actual cheese conditions and that the models do not allow direct in situ analysis or that the models involve growing cells, whereas the major part of the cheese ripening process involves non-growing cells. Moreover, the studies with the real cheese-like models, such as the CH-easy model, various curd models or cheese juices, are still hampered by difficulty/impossibility of perturbations and extractions. Hence, there is a clear need for alternative, improved, approaches.

Earlier studies by the group of Mireille Yvon and others [36-40] have shown that resting, non-growing, cells of various microorganisms actually convert amino acids into flavour components. The conversion of the branched chain amino acid L-Leucine to isovaleric acid, for example, was studied in a phosphate buffer using resting cells and cell free extracts of Propionibacterium. In this same study it was shown that addition of a-ketoglutarate was essential for the conversion of L-Leucine to a-ketoisocaproic acid by P.jreudenreichii [39]. Using a similar experimental setup, the ability of resting, non-starter, Lactobacilli and thermophilic lactic acid bacteria to produce various flavour compounds from amino acids were studied [40]. In these studies it was also shown that addition of a-ketoglutarate is not required for flavour formation by (resting cells of) Streptococcus thermophilus and that flavour formation in actual Cheddar [34] and semihard cheese [35] is stimulated by addition of a-ketoglutarate.

In this manuscript, we describe a research approach, based on the work of Yvon and co-workers, to study the

role of, non-growing, Lactococcus lactis in flavour development during cheese ripening. The approach allows acceleration of the flavour-forming process by using concentrated cell suspensions and various perturbations and extractions of samples for analysis without major impact on cell physiology. In this study, we did not include the role of the lysis of starter bacteria, although we are fully aware of the importance of lysis in actual cheese ripening [17]. Since the method that we describe here requires only hours of incubation versus weeks and months during cheese ripening, we can assume that lysis will play a much smaller role during buffer incubations than in actual cheese manufacturing. We focussed on some aspects that were not previously studied, such as the role of the (growth) history of the L. lactis cells on the ability to produce flavour components, the strain variability in flavour formation and the difference between simultaneous conversion of various amino acids versus conversion of single amino acids. Furthermore, we demonstrated that biological variance in these flavour-generating experiments can be significantly reduced using frozen cell suspensions deriving from one large fermentation instead of producing new cell material for every individual experiment.

Overall, the analyses reveal important strain- and amino acid availability-dependent flavour formation by Lactococcus lactis.

Results and discussion

Experimental setup

An experimental set-up was used to determine the flavour-forming potential of various L. lactis strains under non-growing conditions. Ten-fold concentrated cell suspensions were made by suspending the cell pastes of the various strains with a final OD600 of 40. By using these 10 fold concentrated cell suspensions relatively rapid detection of flavour formation became possible. Our cell incubation system was validated using L. lactis strain 1157, well-known for its production of 3-methylbutanal and 3-methylbutanol. This strain was incubated in sodium phosphate buffer containing leucine and NADH for 24 h at 30°C followed by GCMS analysis of the volatile

metabolites (Table 1). It was observed that mere incubation of cells in phosphate buffer with various amino acids was not sufficient for the production of 3-methylbutanal or 3-methylbutanol. We observed some formation of these volatiles in the incubation mix with only leucine and glucose (no cells), probably as a result of chemical conversion, i.e. Strecker reaction. In the incubations with cells and sugar (0.2%), we observed significant growth of the bacteria and volatile production which is not related to the production in the non-growing state. Hence, to ensure that the cells were not growing during incubation, sugar addition was aborted for all remaining experiments. In the presence of a-ketoglutarate, we found a nine fold increase in the level of the sum of the aldehyde and alcohol. Extra addition of pyridoxal-5-phosphate led to a tenfold increase of these same flavour compounds as compared to the incubation of just leucine and cells. Rapid freezing (in liquid nitrogen) storage at -40°C and thawing in a water bath at 30°C had no particular effect on the production of volatiles when the concentrated cells (optical density of 400 at 600 nm) were incubated in 100 mM sodium phosphate buffer (pH 6.0) with 15% gly-cerol (data not shown). This allowed the usage of a constant cell biomass which is essential for performing technical replicates. The finding that addition of a-ketoglutarate, and pyridoxal-5-phosphate was required to achieve a high flavour production is consistent with findings of previous studies where a-ketoglutarate was required to confirm aminotransferase activity [32] and enhancement of flavour compound production in Cheddar cheese [36]. Hence, we have used these additions in all remaining experiments.

Strain dependent flavour profile of non-growing strains

Subsequently, the buffer incubation system was used to compare volatile production by five different L. lactis strains. Clear differences were observed in production of some important volatiles as highlighted in the GCMS profiles (Figure 1). All strains produced a range of volatile components, although there were obvious differences in production levels of volatiles and in variety of volatiles produced.

Table 1 Development of incubation mixture for volatile production by non-growing cells

3-methylbutanal Fold change 3-methylbutanol Fold change

leucine + cells 1.0E + 08 1.0 2.2E + 07 1.0

leucine + glucose 6.4E + 06 0.1 3.8E + 06 0.2

leucine + glucose + cells 2.5E + 08 2.4 5.7E + 07 2.6

leucine + a-ketoglutarate + cells 3.6E + 08 3.6 7.7E + 08 35.2

leucine + a-ketoglutarate + pyrydoxal-5-phosphate + cells 6.2E + 08 6.2 5.9E + 08 27.1

Fold change is displayed against the incubation with leucine and cells.

Effect of a-ketoglutarate and pyridoxal phosphate on 3-methyl butanal and 3-methyl butanol production (GCMS-peak area) by L.lactis 1157 in a buffer system containing 100 mM phosphate, pH 6,0, 2 mM NADH and 10 mM leucine.

Figure 1 Volatile compound production of non-growing Lactococcus lactis strains. L.lactis KF147, SK11, 1157, MG1363 and IL1403 in a buffer system containing 100 mM sodium phosphate, pH 6.0, 2 mM NADH, 10 mM a-ketoglutarate, 0.1 mM pyridoxalphosphate and the amino acid mixture. Displayed volatile compounds: A: 2-methylpropanal, B: 2-methylpropanol, C: 3-methylbutanal, D: 2-methylbutanal, E: phenylacetaldehyde, F:3-methylbutylvalerate, G: 2-isopropyl-5-methyl-2hexenal.

All strains produced volatile compounds, although two strains, L. lactis MG1363 and IL1403 were only observed to produce 2-methylpropanal, 3-methylbutanal, and 2-methyl butanal, all products from branched chain amino acid conversions [41]. Strains SK11, 1157, and KF147 exclusively produced the volatile 2-methylpropanol, likely to be a direct result of valine conversion. These three strains also produced phenylacetaldehyde from phenyl-alanine degradation whereas MG1363 and IL1403 did not produce this flavour compound, indicating that phenylacetaldehyde production is a result of microbiological activity and not of chemical conversion in these incubation mixtures. There were also clear differences observed in flavour profiles when SK11, 1157, and KF147 were compared. For example in the conversion of leucine and isoleucine, strain 1157 produced the highest amounts of the flavours 3-methylbutanal and 2-methylbutanal. Moreover, it was observed that strain SK11 produced the

aldehyde 2-methylpropanal but not the corresponding alcohol 2-methylpropanol, whereas this aldehyde and alcohol were found in incubations with strain 1157 and KF147. Strain 1157 uniquely produced two fruity flavours: 2-isopropyl-5-methyl-2-hexenal and 3-methylbutylvalerate.

These data on strain-specific amino acid conversions reiterate the importance of strain selection for industrial fermentations where good and distinct flavours are the main objective.

Influence of growth phase and amino acid availability on flavour formation

To assess the influence of the bacterial growth phase on flavour formation, cells of L. lactis strain 1157 were studied at two different time-points during cultivation, in the growing and the non-growing phase in a buffer system (Table 2). It was observed that 2-butanone, acetic acid, acetone, diacetyl and DMDS were only produced by

Table 2 Flavour production at different growth stages

Non-growing Growing Ratio (n-gr/gr)

2-butanone n.d.a 7.2 X 107 _b

Acetic acid n.d. 4.3 X 106 -

Acetone n.d. 8.7 X 107 _

Diacetyl n.d. 6.4 X 107 _

DMDS n.d. 3.0 X 107 _

2-methylpropanol 8.7 X 107 n.d. +

n-butylisovalerate 2.6 X 106 n.d +

3-methylbutyl-2-methylbutyrate 1.1 X 107 n.d +

Methylbenzoate 9.1 X105 n.d +

2-isopropyl-5-methyl-2-hexanal 2.9 X107 n.d +

4-methyl-2-phenyl-2-hexanal 1.1 X 107 n.d +

2-methylpropanal 8.9 X 108 5.0 X 108 2

3-methylbutanal 9.5 X 108 8.7 X 108 1

2-methylbutanal 8.8 X 108 8.7 X 108 1

3-methylbutanol 1.2 X 108 2.7 X 108 0.5

2-methylbutanol 1.7 X 108 9.4 X 107 2

Benzaldehyde 1.8 X 107 4.0 X 106 5

Phenylacetaldehyde 2.3 X 108 2.6 X 107 9

5-methyl-2-phenyl-2-hexenal 1.7 X 108 2.5 X 106 70

Volatile compound production (GCMS-peak areaa,b) of incubations of L. lactis 1157 during growth in CDM and under non-growing conditions in a buffer system containing 100 mM sodium phosphate, pH 6.0, 2 mM NADH, 10 mM a-ketoglutarate, 0.1 mM pyridoxal phosphate and a mixture of 18 amino acids. an.d, not detected.

b- and +, not produced or only produced by non-growing cells in comparison to growing cells respectively.

growing cells. In contrast, 2-methylpropanol, methylbenzo-ate and some of the esters such as «-butyl isovalerate, 3-methylbutyl-2-methylbutyrate, 2-isopropyl-5-methyl-2-hexanal and 4-methyl-2-phenyl-2-hexenal were only produced by non-growing cells. Benzaldehyde, pheny-lacetaldehyde [42] methylbenzoate, and 5-methyl-2-phenyl-2-hexenal, all products of aromatic amino acid conversions were clearly produced at higher levels by non-growing cells compared to growing cells. However, 2-methylpropanal, 2-methylbutanal, 3-methylbutanal, 2-methylbutanol and 3-methylbutanol, products of branched chain amino acids, were produced in similar amounts in growing and non-growing cells. Overall, the fact that several flavours were produced at distinctly different levels for growing and non-growing cells establishes the relevance of this developed assay. To show possible interaction between the individual amino acid conversion routes, non-growing cells of L. lactis 1157 were incubated with either single amino acids or a mixture of 18 amino acids. Clear differences were observed in the absolute amounts of individual flavour components

and ratio between the various flavour components when single substrates or substrate mixtures were used. Some volatile metabolites were only produced upon incubation with single amino acids, while others were only produced in the complete amino acid mix (Table 3). Some of the observed volatile compounds appeared to be uniquely produced from a specific amino acid, such as 3-methylpentanal, 3-methylbutylvalerate, 2,6-nonadienal and 5-methyl-2-isopropyl-2-hexenal from leucine, benzaldehyde and phenylacetaldehyde from phenylalanine and methanethiol, dimethylsulfide and dimethyldisul-fide from methionine. However, compounds such as 3-methylbutanal and 2-methylbutanal which are usually produced from branched-chain amino acids [41], were also formed upon incubation with aromatic amino acids and with methionine although the concentration in absence of leucine is 100 - 300-fold lower. Interestingly, some of the compounds observed in single amino acid incubations - methanethiol, dimethylsulfide, dimethyldi-sulfide, 3-methylpentanal - were not found in the incubations with the complete amino acid mix. For instance, sulphur containing products such as dimethyldisulfide, dimethyltrisulfide and methanethiol were only found when methionine was offered as the single amino acid substrate. This phenomenon was also observed when phenylalanine was the single amino acid substrate, but also uniquely benzaldehyde production was observed. Apparently, the different amino acid converting enzymes, and most probably the amino-transferases, seem to compete for their individual amino acid substrates in this model system. Such substrate interactions and competitions will probably also occur during complicated food fermentations and can be elucidated using an experimental set-up as described here. If enzyme or subtrate competition occurs during cheese ripening it may have a huge impact on developing the flavour profile during ripening. We also confirmed that flavour formation is highly strain- and growth phase-dependent. In previous studies using growing cells of L. lactis SK11 and MG1363, it was shown that these strains were not capable of producing 3-methylbutanal in M17-medium [43]. However, in the current study we found that these strains actually are able to produce this relevant flavour compound under non-growing conditions. Two of the L. lactis strains in this study (MG1363 and IL1403) produced significantly lower amounts of volatiles compared to the other three strains tested. Both these low-flavour-producing strains are well-studied, plasmid-free, model strains [44,45]. While other explanations are possible, this suggests that some flavour-generating activities are encoded on lactococcal plasmids, a phenomenon that is currently being investigated. Overall, this data clearly confirm that all these flavour compounds are actually produced through the conversion of amino acids and not from any other

Table 3 Amino acid dependent flavour production

Methionine Leucine Phenylalanine Tyrosine aa-mix Reference

2-methylpropanal 1.0 X 108 9.5 X 107 1.2 X 107 2.2 X107 5.7 X 109 n.d.a

2-methylpropanol n.d n.d. n.d. n.d. 1.2 X 108 n.d

3-methylbutanal 4.3 X 108 4.0 X 109 1.3 X 108 1.3 X 108 2.2 X 109 n.d.

2-methylbutanal 2.5 X 108 5.2 X 108 4.6 X 107 6.0 X 107 1.5 X 109 n.d.

DMDS 8.3 X 107 n.d. n.d. n.d. n.d. n.d.

3-methylpentanal n.d. 3.8 X 107 n.d. n.d. n.d. n.d.

Methional 5.2 X 108 n.d. n.d. n.d. n.d. n.d.

2,6-nonadienal n.d. 4.1 X 108 n.d. n.d. 5.7 X107 n.d.

DMTS 1.1 X 107 n.d. n.d. n.d. n.d. n.d.

Benzaldehyde n.d. n.d. 3.2 X 108 n.d. n.d. n.d.

Phenylacetaldehyde n.d. n.d. 3.1 X 109 n.d. 5.8 X 108 n.d.

3-methylbutylvalerate n.d. 9.5 X 107 n.d. n.d. 1.4 X 107 n.d.

5-methyl-2-isopropyl-2-hexenal n.d. 2.0 X 109 n.d. n.d. 3.8 X 107 n.d.

Volatile compound production (GCMS-peak areaa) of incubations of L. lactis 1157 in a buffer system containing 100 mM sodium phosphate, pH 6.0, 2 mM NADH, 10 mM a-ketoglutarate, 0.1 mM pyridoxal phosphate, 10 mM methionine, 10 mM tyrosine, 10 mM phenylalanine, 10 mM leucine or 18 amino acids where 13 volatiles are presented (AA-mix). an.d, not detected.

The reference is the complete incubation mixture without amino acids.

substrate since these were not made available in the assays. Ayad [46] reported production of the alcohols, etha-nol, 2-methyl propanol in cheese paste or in a milk culture by strain L.lactis 1157 which is consistent with the results, with the addition that we now show that 2-methylpropanol is exclusively produced under non-growing conditions (Table 2). Ayad also reported the production of the aldehydes 2-methylpropanal, 2- methyl-butanal, 3-methylbutanal and benzaldehyde. In addition to that finding we have found that 2-methylpropanal is produced at a two-fold higher level and benzaldehyde at a five-fold higher level under non-growing conditions, while 3-methylbutanal and 2-methylbutanal are produced in similar quantities under growing and non-growing conditions. Furthermore, the results show exclusive acetone, diacetyl, butanone and DMDS production under growing conditions support the high levels observed in fermented milk cultures and lower levels in cheese paste incubations reported by Ayad. The observed differences between the cheese paste cultivation and buffer incubations could be explained by the absolute absence of any carbon source in our case and the presence of citrate as additional substrate in the case of the cheese paste model. Using a microcheese model where different strains of L. lactis were added as adjunct cultures in Gouda cheese production, Bachmann found increased production of diacetyl using strains IL1403 (78%) and SK11 (25%), but not using strain 1157, and increased production of 3-methylbutanal using strains 1157 and SK11 which is consistent with our results. These comparisons with actual, experimental, dairy products demonstrate

that this rapid method for studying flavour formation by non-growing lactic acid bacteria provides relevant flavour information for actual production of cheese and other fermented dairy products. Furthermore it enables the study of single amino acid conversions and can be used as tool to compare production of flavour components under growing and non-growing conditions.


The majority of flavour production in fermented foods, including cheese, occurs during the extended non-growing phase of lactic acid bacteria. We have chosen to use and further develop an existing experimental method to study the role of Lactococcus lactis in cheese flavour production. The method uses active cells, harvested in the stationary growth phase, and resuspended at high concentrations in physiological buffer, at relevant pH-values with the addition of several co-factors known to be involved in flavour production such as NADH, a-ketoglutarate and pyridoxal-phosphate. We use the method to demonstrate that; 1. There are major differences in amino acid conversion by different (non-growing) L. lactis strain resulting in large variations in flavour profiles, 2. The conditions of the L. lactis cells (growing versus non-growing) has a major impact on their flavour production, 3. The conversion of amino acid mixtures is not just a simple addition of the conversion reaction of each single amino acid 4. The use of concentrated suspensions of non-growing L. lactis cells is a suitable method to study flavour production during ripening of semi-hard cheeses, and 5. The method can be used for rapid

evaluation of flavour formation since it allows the use of concentrated cell suspensions.


Bacterial strains and concentrated strain stocks

Lactococcus lactis strains MG1363 [45], SK11 [47] and KF147 [48], as well as L. lactis strains IL1403 [44] and 1157 [46] were routinely cultivated in M17-medium containing 0.5 % glucose (MG1363 and IL1403) or 0.5% lactose (KF147, SK11 and 1157). After overnight incubation (30°C), stationary phase cells were harvested by cen-trifugation at 6000 xg at 4°C. Cells were washed twice with 100 mM sodium phosphate buffer (pH 6.0) and re-suspended in the same buffer with 15% glycerol at an optical density of 400 at 600 nm (OD600). Aliquots of these cell suspensions were quickly frozen in liquid nitrogen and stored at -40°C.

When experiments were performed with growing cells, L. lactis strain 1157 was incubated in Chemical Defined Medium (CDM) [49] with lactose as carbon and energy source. The cultures were harvested, as described earlier, by centrifugation just before entering the stationary phase.

Buffer incubation

Volatile production by non-growing cells was studied in 100 mM sodium phosphate buffer (pH6.0) with various additions. a-ketoglutarate (10 mM), NADH (0.2 mM), pyridoxal-5-phosphate (0.1 mM) and 18 amino acids; alanine, arginine, aspartic acid, cysteine, glutamic acid, histidine, isoleucine, leucine, lysine, phenylalanine, proline, serine, threonine, tryptophan, valine, glycine, tyrosine and methionine (10 mM) were added to the cell suspensions when incubated in this buffer system. After thawing, concentrated cells were added to a final OD600 of 40 in the incubation mix. GC vials of 10 ml were filled with 3 ml incubation mixtures and closed with caps to prevent evaporation of volatile compounds. To correct for chemical formation of volatiles, incubation mixtures without cells were performed as controls. Incubations with growing cells were performed in biological triplicates, whereas buffer incubations with single amino acids were performed as a single incubation. This was the consequence of the limited number of samples which could be measured in one G CMS-run and we preferred more variation in incubation conditions and strains used over duplicate or triplicate analysis. From previous fermentation work in our laboratory involving flavour-generation [50] we built sufficient confidence in the high reproducibility in product formation of duplicate and triplicate samples to allow such as choice. After incubation for 24 h at 30°C, the incubation was terminated by flash-freezing of the vials in liquid nitrogen. The vials were stored at -40°C prior to flavour analysis.

GC-MS analysis

Volatile compounds were measured in the headspace of the incubated samples with the use of Headspace Solid Phase Dynamic Extraction (HS-SPDE) method coupled to a gas chromatograph (trace GC ultra; Thermo Scientific) and mass spectrometer (Thermo Scientific) using a source temperature of 280°C and a transferline temperature of 250°C. After equilibration for 10 minutes at 60°C, the volatile compounds were concentrated onto the phase of the needle by introducing the sample repeatedly through the needle (stationary phase PDMS/AC). The compounds were then desorbed from the syringe needle into the injector (250°C) followed by cryo fixation at -110°C onto the beginning of the analytical column. The cold trap was rapidly heated to 250°C and the compounds were separated on a VF-1 ms column. (Varian, CP8930: 60 m x

0.32 mm, DF = 1,0 |im). The column temperature was initially 40°C for 2 minutes, then gradually raised to 250°C with 10°C/min and subsequently held at that temperature for 5 minutes. The mass spectrometer was operated in a full scanning mode (m/z 25-250) using electron impact ionization (70 eV). The carrier gas was helium, with a constant flow of 1,5 ml/min. Compound structures were assigned by retention time index and the MS spectrum interpretation, quantification and comparison of the spectra were performed using the bibliographic NIST/EPA/ NIH Mass Spectral Library (NIST, USA) and Wiley Mass Spectral Library (John Wiley and Sons, USA).

Competing interests

The authors declare that they have no competing interests. Authors' contributions

BvdB developed and used this method to study flavour forming metabolic routes under supervision of PB. Project leader LS, WMdV and JH supervised the whole setup of this method. All authors read and approved the final manuscript.


We gratefully acknowledge Jan van Riel and Wilma Wesselink (NIZO food research, (Ede, The Netherlands) for their excellent assistance with GCMS measurements. We also thank Nicolas Flahaut and Peter Schaap of (Laboratory of Microbiology, Wageningen University, The Netherlands) for fruitful discussions.

Author details

1TI Food and Nutrition, Wageningen, The Netherlands. 2NIZO food research, Ede, The Netherlands. 3The Kluyver Centre for Genomics of Industrial Fermentations/NCSB, Delft, The Netherlands. 4Wageningen UR Food & Biobased Research, Wageningen, The Netherlands. 5Laboratory of Microbiology, Wageningen University, Wageningen, The Netherlands. 6Department Veterinary Biosciences, University of Helsinki, Helsinki, Finland. 7University of Amsterdam, Swammerdam Institute of Life Sciences, Science park 904, PO Box 94216, 1090, GE Amsterdam, The Netherlands.

Received: 13 June 2014 Accepted: 28 November 2014 Published online: 10 December 2014


1. Visser S: Proteolytic enzymes and their relation to cheese ripening and flavor: an overview. J Dairy Sci 1993, 76:329-350.

Konings WN, Poolman B, Driessen AJM, Maloney PC: Bioenergetics and 26.

solute transport in lactococci. Crit Rev Microbiol 1989, 16:419-476.

Smid EJ, Poolman B, Konings WN: Casein utilization by lactococci. 27.

Appl Environ Microbiol 1991, 57:2447-2452.

Kunji ERS, Mierau I, Hagting A, Poolman B, Konings WN: The proteotytic

systems of lactic acid bacteria. Antonie Van Leeuwenhoek 1996, 28.


Pritchard GG, Coolbear T: The physiology and biochemistry of the

proteolytic system in lactic acid bacteria. FEMS Microbiol Rev 1993, 29.


Siezen RJ: Multi-domain, cell-envelope proteinases of lactic acid bacteria.

Antonie Van Leeuwenhoek 1999, 76:139-155. 30.

Savijoki K, Ingmer H, Varmanen P: Proteolytic systems of lactic acid bacteria. Appl Microbiol Biotechnol 2006, 71:394-406.

Bachmann H, Starrenburg MJC, Dijkstra A, Molenaar D, Kleerebezem M, 31.

Rademaker JLW, van Hylckama Vlieg JET: Regulatory phenotyping reveals important diversity within the species Lactococcus lactis. Appl Environ Microbiol 2009, 75:5687-5694.

Wouters JTM, Ayad EHE, Hugenholtz J, Smit G: Microbes from raw milk for 32.

fermented dairy products. Int Dairy J 2002, 12:91-109.

Ayad EHE, Verheul A, Wouters JTM, Smit G: Application of wild starter

cultures for flavour development in pilot plant cheese making. Int Dairy J 33.

2000, 10:169-179.

Brandsma JB, Floris E, Dijkstra ARD, Rijnen L, Wouters JA, Meijer WC: Natural diversity of aminotransferases and dehydrogenase activity in a large 34.

collection of Lactococcus lactis strains. Int Dairy J 2008, 18:1103-1108. Ganesan B, Dobrowolski P, Weimer BC: Identification of the leucine-to-2-methylbutyric acid catabolic pathway of Lactococcus lactis. Appl Environ 35. Microbiol 2006, 72:4264-4273.

García-Cayuela T, de Cadiñanos LP G, Peláez C, Requena T: Expression in Lactococcus lactis of functional genes related to amino acid catabolism and cheese aroma formation is influenced by branched chain amino 36.

acids. Int J Food Microbiol 2012, 159:207-213.

Brandsma JB, van de Kraats I, Abee T, Zwietering MH, Meijer WC: Arginine metabolism in sugar deprived Lactococcus lactis enhances survival and cellular activity, while supporting flavour production. Food Microbiol 2012, 37. 29:27-32.

Bachmann H, KruijswijkZ, Molenaar D, Kleerebezem M, van Hylckama Vlieg JET: A high-throughput cheese manufacturing model for effective cheese starter 38. culture screening. J Dairy Sci 2009, 92:5868-5882. Wilkinson MG, Guinee TP, Fox PF: Factors which may influence the determination of autolysis of starter bacteria during cheddar cheese 39.

ripening. Int Dairy J 1994, 4:141-160.

Crow VL, Coolbear T, Gopal PK, Martley FG, McKay LL, Riepe H: The role of autolysis of lactic acid bacteria in the ripening of cheese. Int Dairy J 1995, 40. 5:855-875.

Engels WJM, Dekker R, de Jong C, Neeter R, Visser S: A comparative study of volatile compounds in the water-soluble fraction of various types of 41. ripened cheese. Int Dairy J 1997, 7:255-263.

Milo C, Reineccius GA: Identification and quantification of potent 42.

odorants in regular-Fat and Low-Fat mild cheddar cheese. J Agric Food Chem 1997, 45:3590-3594.

Varming C, Andersen LT, Petersen MA, Ardö Y: Flavour compounds and 43.

sensory characteristics of cheese powders made from matured cheeses.

Int Dairy J 2013, 30:19-28.

Van Leuven I, Van Caelenberg T, Dirinck P: Aroma characterisation of

Gouda-type cheeses. Int Dairy J 2008, 18:790-800. 44.

Van Hoorde K, Van Leuven I, Dirinck P, Heyndrickx M, Coudijzer K,

Vandamme P, Huys G: Selection, application and monitoring of

Lactobacillus paracasei strains as adjunct cultures in the production of 45.

Gouda-type cheeses. Int J Food Microbiol 2010, 144:226-235.

Smit G, Braber A, Van Spronsen W, Van Den Berg G, Exterkate FA: Ch-Easy

Model: a Cheese-Based Model to Study Cheese Ripening. In Bioflavour 95. 46.

Edited by Étiévant P, Schreier P. Dijon, Paris, France: INRA; 185-190.

González L, Sacristán N, Arenas R, Fresno JM, Eugenia Tornadijo M:

Enzymatic activity of lactic acid bacteria (with antimicrobial properties) 47.

isolated from a traditional Spanish cheese. Food Microbiol 2010,


Yvon M, Gitton C, Chambellon E, Bergot G, Monnet V: The initial efficiency of the proteolytic system of Lactococcus lactis strains determines their responses to a cheese environment. Int Dairy J 2011, 21:335-345.

Kaminogawa S, Ninomiya T, Yamauchi K: Aminopeptidase profiles of Lactic

streptococci. J Dairy Sci 1984, 67:2483-2492.

Kenny O, FitzGerald RJ, O'Cuinn G, Beresford T, Jordan K: Growth phase and growth medium effects on the peptidase activities of Lactobacillus helveticus. Int Dairy J 2003, 13:509-516.

Christensen JE, Dudley EG, Pederson JA, Steele JL: Peptidases and amino acid catabolism in lactic acid bacteria. Antonie Van Leeuwenhoek 1999, 76:217-246.

Gao S, Mooberry ES, Steele JL: Use of 13C nuclear magnetic resonance and Gas chromatography to examine methionine catabolism by Lactococci. Appl Environ Microbiol 1998, 64:4670-4675. Ziadi M, Bergot G, Courtin P, Chambellon E, Hamdi M, Yvon M: Amino acid catabolism by Lactococcus lactis during milk fermentation. Int Dairy J 2010, 20:25-31.

Rijnen L, Bonneau S, Yvon M: Genetic characterization of the major Lactococcal aromatic aminotransferase and its involvement in conversion of amino acids to aroma compounds. Appl Environ Microbiol 1999, 65:4873-4880.

Yvon M, Thirouin S, Rijnen L, Fromentier D, Gripon J: An aminotransferase from Lactococcus lactis initiates conversion of amino acids to cheese flavor compounds. Appl Environ Microbiol 1997, 63:414-419. Klein N, Maillard MB, Thierry A, Lortal S: Conversion of amino acids into aroma compounds by cell-free extracts of Lactobacillus helveticus. J Appl Microbiol 2001, 91:404-411.

Exterkate FA, Alting AC: The role of starter peptidases in the initial proteolytic events leading to amino acids in Gouda cheese. Int Dairy J 1995, 5:15-28.

Le Boucher C, Courant F, Jeanson S, Chereau S, Maillard MB, Royer AL, Thierry A, Dervilly-Pinel G, Le Bizec B, Lortal S: First mass spectrometry metabolic fingerprinting of bacterial metabolism in a model cheese.

Food Chem 2013, 141:1032-1040.

Banks JM, Yvon M, Gripon JC, de la Fuente MA, Brechany EY, Williams AG, Muir DD: Enhancement of amino acid catabolism in Cheddar cheese using alpha-ketoglutarate: amino acid degradation in relation to volatile compounds and aroma character. Int Dairy J 2001, 11:235-243. Yvon M, Berthelot S, Gripon JC: Adding a-ketoglutarate to semi-hard cheese curd highly enhances the conversion of amino acids to aroma compounds. Int Dairy J 1998, 8:889-898.

Helinck S, Le Bars D, Moreau D, Yvon M: Ability of thermophilic lactic acid bacteria to produce aroma compounds from amino acids. Appl Environ Microbiol 2004, 70:3855-3861.

Thierry A, Maillard M-B, Yvon M: Conversion of l-Leucine to Isovaleric Acid by Propionibacterium freudenreichii TL 34 and ITGP23. Appl Environ Microbiol 2002, 68:608-615.

Kieronczyk A, Skeie S, Olsen K, Langsrud T: Metabolism of amino acids by resting cells of non-starter lactobacilli in relation to flavour development in cheese. Int Dairy J 2001, 11:217-224.

Yvon M, Rijnen L: Cheese flavour formation by amino acid catabolism.

Int Dairy J 2001, 11:185-201.

Nierop Groot MN, de Bont JAM: Conversion of Phenylalanine to Benzaldehyde Initiated by an Aminotransferase in Lactobacillus plantarum. Appl Environ Microbiol 1998, 64:3009-3013. Smit BA, Engels WJM, Wouters JTM, Smit G: Diversity of l-leucine catabolism in various microorganisms involved in dairy fermentations, and identification of the rate-controlling step in the formation of the potent flavour component 3-methylbutanal. Appl Microbiol Biotechnol 2004, 64:396-402. Bolotin A, Wincker P, Mauger S, Jaillon O, Malarme K, Weissenbach J, Ehrlich SD, Sorokin A: The complete genome sequence of the Lactic Acid Bacterium Lactococcus lactis ssp. lactis IL1403. Genome Res 2001,11:731-753. Gasson MJ: Plasmid complements of Streptococcus lactis NCDO 712 and other lactic streptococci after protoplast-induced curing. J Bacteriol 1983, 154:1-9.

Ayad EHE, Verheul A, de Jong C, Wouters JTM, Smit G: Flavour forming abilities and amino acid requirements of Lactococcus lactis strains isolated from artisanal and non-dairy origin. Int Dairy J 1999, 9:725-735. Makarova K, Slesarev A, Wolf Y, Sorokin A, Mirkin B, Koonin E, Pavlov A, Pavlova N, Karamychev V, Polouchine N, Shakhova V, Grigoriev I, Lou Y, Rohksar D, Lucas S, Huang K, Goodstein DM, Hawkins T, Plengvidhya V, Welker D, Huges J, Goh Y, Benson A, Baldwin K, Lee J-H, Diaz-Muniz I, Dosti B, Smeianov V, Wechter W, Barabote R, et al: Comparative genomics of the lactic acid bacteria. Proc Natl Acad Sci 2006,103:15611-15616.

48. Siezen RJ, Bayjanov J, Renckens B, Wels M, van Hijum SAFT, Molenaar D, van Hylckama Vlieg JET: Complete Genome Sequence of Lactococcus lactis subsp. lactis KF147, a Plant-Associated Lactic Acid Bacterium.

J Bacterid 2010, 192:2649-2650.

49. Poolman B, Konings WN: Relation of growth of Streptococcus lactis and Streptococcus cremoris to amino acid transport. J Bacterid 1988, 170:700-707.

50. Flahaut NL, Wiersma A, Bunt B, Martens D, Schaap P, Sijtsma L, Santos VM, Vos W: Genome-scale metabolic model for Lactococcus lactis MG1363 and its application to the analysis of flavor formation. Appl Microbiol Biotechnoi 2013, 97:8729-8739.


Cite this article as: van de Bunt et al.: Use of non-growing Lactococcus lactis cell suspensions for production of volatile metabolites with direct relevance for flavour formation during dairy fermentations. Microbial Cell Factories 2014 13:176.

Submit your next manuscript to BioMed Central and take full advantage of:

• Convenient online submission

• Thorough peer review

• No space constraints or color figure charges

• Immediate publication on acceptance

• Inclusion in PubMed, CAS, Scopus and Google Scholar

• Research which is freely available for redistribution

Submit your manuscript at BinMeli rpntr,i v-c"Lml