Scholarly article on topic 'Physiological characteristics of the extreme thermophile Caldicellulosiruptor saccharolyticus: an efficient hydrogen cell factory'

Physiological characteristics of the extreme thermophile Caldicellulosiruptor saccharolyticus: an efficient hydrogen cell factory Academic research paper on "Industrial Biotechnology"

0
0
Share paper
Academic journal
Microb Cell Fact
OECD Field of science
Keywords
{""}

Academic research paper on topic "Physiological characteristics of the extreme thermophile Caldicellulosiruptor saccharolyticus: an efficient hydrogen cell factory"

REVIEW Open Access

Physiological characteristics of the extreme thermophile Caldicellulosiruptor saccharolyticus: an efficient hydrogen cell factory

Karin Willquist*, Ahmad A Zeidan, Ed WJ van Niel

•J MICROBIAL CELL FACTORIES

Abstract

Global concerns about climate changes and their association with the use of fossil fuels have accelerated research on biological fuel production. Biological hydrogen production from hemicellulose-containing waste is considered one of the promising avenues. A major economical issue for such a process, however, is the low substrate conversion efficiency. Interestingly, the extreme thermophilic bacterium Caldicellulosiruptor saccharolyticus can produce hydrogen from carbohydrate-rich substrates at yields close to the theoretical maximum of the dark fermentation process (i.e., 4 mol H2/mol hexose). The organism is able to ferment an array of mono-, di- and polysaccharides, and is relatively tolerant to high partial hydrogen pressures, making it a promising candidate for exploitation in a biohydrogen process. The behaviour of this Gram-positive bacterium bears all hallmarks of being adapted to an environment sparse in free sugars, which is further reflected in its low volumetric hydrogen productivity and low osmotolerance. These two properties need to be improved by at least a factor of 10 and 5, respectively, for a cost-effective industrial process. In this review, the physiological characteristics of C. saccharolyticus are analyzed in view of the requirements for an efficient hydrogen cell factory. A special emphasis is put on the tight regulation of hydrogen production in C. saccharolyticus by both redox and energy metabolism. Suggestions for strategies to overcome the current challenges facing the potential use of the organism in hydrogen production are also discussed.

1. Introduction

Anthropogenic CO2 emissions have generally been recognized as the major contributor to global warming and associated climate changes. Therefore, several measures are being taken to decrease the CO2 emission. In recent years, much effort has been devoted to rendering biofuel production economically competitive to that of fossil fuels, since this will contribute significantly to the reduction of energy-linked environmental impacts. In this quest, the choice of the raw material is of central concern. First-generation biofuels are produced from sucrose and starch-rich substrates, which may compete with human consumption - inevitably driving up market prices. As a remedy, more focus should be directed to second-generation biofuels, produced from non-edible lignocellulosic materials, the most naturally abundant

* Correspondence: karin.willquist@tmb.lth.se

Applied Microbiology, Lund University, Getingevagen 60, SE-222 41 Lund, Sweden

raw material [1], as well as domestic and industrial wastes. The accompanying significant cost reductions should make biofuels more competitive.

Biohydrogen is a typical example of an environmentally friendly biofuel, with no CO2 emission resulting from its combustion. It can be produced from both lig-nocellulosic and waste materials [2-5], through biological conversion processes, such as dark fermentation and photofermentation. In the latter, biohydrogen can be produced using purple sulphur or non-sulphur bacteria that convert organic acids to H2 in photon-driven reactions [6,7]. Although a combination of these two processes is an interesting approach for maximum conversion of the energy contained in carbohydrate-rich substrates into H2 [8], only dark fermentative H2 production is covered in this review.

In total, 12 H2 molecules can be obtained per mole of glucose, based on the overall number of electrons that can be generated in the complete oxidation of the latter. However, dark fermentation is limited to a maximum

O© 2010 Willquist et al; licensee BioMed Central Ltd. This is an Open Access article distributed under the terms of the Creative CGntfcll Commons Attribution License (http://creativecommons.Org/licenses/by/2.0), which permits unrestricted use, distribution, and reproduction in any medium, provided the original work is properly cited.

H2-production efficiency of 33%, i.e., maximally four molecules of H2 can be acquired per molecule of glucose with acetate and CO2 as the other fermentation end products [9]. Yet, this is only possible when the H2 partial pressure (PH2) is kept adequately low [10], e.g. by continuous stripping of the produced H2 with an inert gas. However, for a cost-effective dark fermentation process it is vital to obtain significantly high H2 yields at relatively elevated PH2, due to the high impact of central costs of feedstock and gas upgrading [11]. Generally, mesophilic (co-)cultures reach H2 yields of < 2 moles/ mol hexose [12], thus exemplifying conversion efficiencies of merely 17%. In addition, these yields are obtained at low PH2 only [6]. On the other hand, based on ther-modynamic aspects, thermophilic bacteria and archaea may produce up to the theoretical maximum of 4 mol H2/mol hexose [13]. In general, the low H2 yields obtained in practice by different organisms, in addition to the requirement for low PH2, are major obstacles that need to be overcome before biohydrogen production can be industrially feasible [6].

Caldicellulosiruptor saccharolyticus is an extreme thermophilic bacterium that can produce high H2 yields [14,15], and at the same time is relatively insensitive to high PH2 [16]. This organism has recently gained increased interest due to its ability to produce thermostable cellulolytic and xylanolytic enzymes [17-21], to grow on complex lignocellulosic carbon sources [2,22,23], and to co-metabolize a wide spectrum of monosaccharides including both pentose and hexose sugars [24]. Although C. saccharolyticus possesses these desirable traits and several research articles have been recently published on this heterotrophic strict anaerobe, it has not yet been the subject of a review article. Herein, the physiological properties of C. saccharolyticus will be analyzed to unravel the characteristics required for a superior H2 cell factory. To further underline current insights in this topic, the physiology of C. saccharolyticus will be compared with that of other H2-producing microorganisms.

2. Characteristics and natural habitat of C. saccharolyticus

C. saccharolyticus is a strictly anaerobic, extreme-ther-mophilic, Gram-positive bacterium that belongs to the Clostridia class. There are to date 13 characterized species in the genus Caldicellulosiruptor, of which C. saccharolyticus is described best, including its whole-genome sequence [25]. C. bescii, formerly known as Anaerocellum thermophilum, is the other species in the genus with its genome also fully sequenced [26,27]. C. saccharolyticus was isolated from a piece of wood in a hot spring in the Rotorua-Taupo thermal area in New Zealand, of which the waters have neutral pH, and are

low in sulphate, salt content and free sugars [28]. Instead, The majority of the sugars present in this environment, such as glucose and xylose, are contained in complex (hemi)cellulosic polymers, which are difficult to access.

C. saccharolyticus is well adapted to the selective pressure of this habitat through the production of various hydrolyzing enzymes, possession of a wide range of high-affinity transport systems, and absence of glucose-based catabolite repression [24,25,29], which are all attractive properties for using the organism for industrial purposes. However, being sensitive to high osmotic pressures [30,31] is one of the undesirable consequences of adaptation to such environment. Interestingly, C. sac-charolyticus is non-motile and non-sporulating [32], although it possesses a complete set of genes for flagella biosynthesis and several genes required for sporulation [25], signifying a historical genetic record of characteristics that could have been required in past habitats.

3. Genome analysis and carbohydrate utilisation by C. saccharolyticus

The genome of C. saccharolyticus has been sequenced and a microarray-based protocol for genome-wide tran-scriptome analysis has been developed, which is a major convenience for studying and understanding its physiology [25]. C. saccharolyticus has a relatively small genome of 2,970 kb and 2,760 protein-coding open reading frames (ORFs). From the genome-curation project, several new insights were gained such as the unusually high number of transposons and transposable derivatives C. saccharolyticus possesses, as compared with other organisms [25]. Since transposition increases the chance of genetic alterations, a large number of transposons can enhance the adaptability of this organism and may widen the spectrum of environmental conditions it can grow in, which is beneficial from an industrial point of view. On the other hand, this may also have negative repercussions since it can jeopardize stable fermentation processes. How to balance both impacts in practice needs to be further investigated.

A general favourable property of members of the Clos-tridia class is their ability to degrade complex polymers such as cellulosic and lignocellulosic materials [33]. Based on growth analysis, C. saccharolyticus can metabolize various carbon sources ranging from monomers, such as xylose, arabinose, glucose, fructose and galactose to a- and b-linked di- and polysaccharides, such as maltose, lactose, sucrose, starch, pullulan, threhalose, xylan and cellulose [32]. C. saccharolyticus can also grow and produce H2 from complex lignocellulosic materials, both pre-treated, such as Miscanthus hydrolysate [2], sugar beet juice [34] and paper sludge [23], and untreated, such as wheat straw [35], pine wood [22] and bagasse [35].

The fermentation of these raw materials by C. saccharolyticus has yielded H2, CO2 and acetate as the main metabolic end products [2,23,34,35], with a maximum H2 yield per consumed hexose of 3.0-3.8 mol/mol [2,34,35]. Interestingly, cultivations on Miscanthus hydrolysate were accompanied by complete depletion of oligosac-charides and simultaneous oligosaccharide and monosac-charide consumption [2]. C. saccharolyticus degrades complex polymers by producing several cellulolytic and xylanolytic enzymes [21]. Properties of the cellulase and hemicellulase enzymes of this organism as well as their gene structures have been extensively studied [21]. In contrast to cellulolytic clostridia [33], C. saccharolyticus does not contain a cellulosome complex. C. saccharolyti-cus is unusual with respect to its possession of a multifunctional, multi-domain organisation for the majority of its ß-glucanases [29]. The majority of the xylanases in C. saccharolyticus are clustered in a large gene cluster, and another cluster of genes involved in xylose metabolism is in close proximity [21]. Detailed information on glycoside hydrolases and other carbohydrate active enzymes encoded by C. saccharolyticus genome can be retrieved from the Carbohydrate Active Enzymes database (CAZy; http://www.cazy.org/; [36]).

The manual curation of the genome sequence of C. saccharolyticus indicated that it possesses an unusually high number of ATP-binding cassette (ABC) transporter genes (i.e., at least 177 ABC transporter genes) [25]; many of which are responsible for the transport of monomeric and dimeric sugars. C. saccharolyti-cus has only one sugar phosphotransferase system (PTS), which is believed to be used for fructose transport [24,25]. When C. saccharolyticus was cultivated on a mixture of monosaccharides, they were consumed simultaneously but at different rates, i.e., fructose > ara-binose > xylose > mannose > glucose > galactose. Unlike the case with disaccharides, the ABC transporters were not substrate specific for these monosaccharides. Instead, the affinity for the different sugars varied, with a clear preference for pentose sugars. Overall, the genome and transcription analyses revealed that C. sac-charolyticus is well equipped for utilizing complex carbohydrates, such as starch and lignocellulosic poly-saccharides [25].

4. Hydrogen yields

For cost-efficient biohydrogen production, it is critical to achieve high substrate-conversion efficiencies due to the central cost of the raw material and the need to reduce the chemical oxygen demand (COD) in the waste stream [6]. Strategies to improve the overall process yield include the application of hybrid two-step systems, consisting of a dark fermentation step combined with either a light fermentation step [37], or a methanogenesis step

[4,38]. In this way, the products of the first fermentation process, consisting mainly of volatile fatty acids, can be converted in the second step to either H2 and CO2 or CH4 and CO2, respectively. The pros and cons of these two strategies were evaluated in a recent review [6] and will not be treated herein. Instead, we will focus on H2 yields of the dark fermentation step.

4.1 Metabolic pathways for hydrogen production

During fermentation, H2 is produced by anaerobic heterotrophs as a means to reoxidize their reducing equivalents. The maximum obtainable yield in a dark fermentation process is 4 moles H2 per mol of hexose, the so-called Thauer limit [9]. However, many H2 yields reported in literature are less than 50% of the Thauer limit (Table 1).

The maximum H2 yield obtained during sugar oxidation depends primarily on the catabolic pathway employed. C. saccharolyticus, with its H2 yields close to the Thauer limit [9], employs the Embden-Meyerhof-Parnas (EMP) pathway to oxidize glucose to pyruvate [14]. The genome sequence and 13C-NMR analysis revealed a complete gene setup for the EMP pathway and the non-oxidative part of the pentose phosphate pathway (PPP) [14,25], which enables the organism to convert different sugars into precursor metabolites and energy. No essential genes for the Entner-Doudoroff (ED) pathway have been found [14,25]. Pyruvate can be oxidized further to acetyl-CoA by pyruvate:ferredoxin oxidoreductase (PFOR), with the generation of reduced ferredoxin (Fdred). Molecular H2 can be obtained from both NADH (two moles of which are generated through the glyceral-dehyde phosphate dehydrogenase (GAPDH)-catalyzed reaction in the EMP pathway) and Fdred, thus resulting in a maximum of 4 mol H2/mol hexose (Figure 1A). Several species of heterotrophic clostridia are also potentially able to produce 4 mol H2/mol hexose, as judged by their metabolic network (Figure 1B), when pyruvate is exclusively oxidized to acetate and CO2. In heterotrophic mesophilic clostridia that carry out acetate-type fermentation, NADH generated in the EMP pathway is reoxi-dized by NADH:Fd oxidoreductase (NFOR) with the generation of Fdred, which is also generated through pyr-uvate oxidation to acetate. The produced Fdred (total 8 mol/mol hexose) can subsequently donate electrons to hydrogenases that reduce protons to H2 [39].

On the other hand, enterobacteria are only able to produce maximally 2 moles H2/mol hexose, since H2 is generated via the hydrolysis of formate being produced from glucose through the pyruvate formate lyase-cata-lyzed pyruvate oxidation (Figure 1C). Interestingly, even the introduction of a synthetic ferredoxin-mediated pyr-uvate-to-H2 pathway in E. coli resulted in low H2 yields (i.e., ~2 mol/mol hexose) [40]. Some of the possible

Table 1 Effect of growth temperature on H2 yield

Organism Opt T °C Cultivation Substrate Maximum yield Reference

Mesophiles

Escherichia coli SR15 37 Fed-batch Glucose 1.82 [85]

Enterobacter aerogenes 40 Batch Glucose 1.0 [99]

Enterobacter cloacae 37 Packed bed Starch 1.4 [100]

Clostridium butyricum 30 continuous Glucose 2 [101]

Clostridium acetobutilicum 34 Fed-batch Glucose 2 [102]

Thermophiles

Clostridium thermocellum 60 Continuous 3.5 [103]

Extreme thermophiles

Thermotoga neopolitana 77 Batch Glucose 3.9 [104]

Thermotoga elfii 65 Batch Glucose 3.3 [15]

Caldicellulosiruptor saccharolyticus 70 Continuous Glucose 3.6 [14]

Caldicellulosiruptor owensensis 70 Batch Glucose 4 [66]

Thermoanaerobacter tengcongensis 75 Batch Glucose 4 [45]

Thermoanaerobacter pseudoethanolicus 70 Continuous Xylose 1.2 [105]

Hyper thermophiles

Thermotoga maritima 80 Batch Glucose 4 [60]

Pyrococcus furiosus 100 Batch Glucose 3.5 [57]

Thermococcales kodakaraensis 88 Continuous Starch 3.3 [106]

A selection of mesophilic, thermophilic and extreme thermophilic H2-producing strains, showing their optimal growth temperature and H2 yields.

reasons why mesophilic bacteria can produce only 2 moles H2/mol hexose, despite being equipped with the relevant metabolic pathways, are revealed in the following sections.

4.2 Thermodynamic aspects

One of the reasons to which the low H2 yields observed in mesophilic cultures have been attributed is the ther-modynamically unfavourable NADH-dependent H2-evolving reaction at PH2 > 0.039 kPa and at standard conditions (1 M concentration of the reactants, 25°C, pH 7) [41]. This is because H2 has a lower formal potential than NADH, hence for the reduction of protons by NADH to occur spontaneously, the PH2 has to be low. However, these conditions are often not encountered even when the reactor is sparged with an inert gas at a high flow rate (i.e., 400 mL/min), because the H2 concentration in the liquid will exceed the critical PH2 a 1000-fold [42]. Therefore, in addition to H2, mesophilic anaerobes normally form other reduced compounds, such as acetone, buta-nol, ethanol, and lactate, resulting in a H2 yield that usually does not exceed 2 mol/mol hexose (Table 1). A strategy to overcome this problem is to use thermophilic hydrogen producers instead, hence this works a decrease in the Gibbs free energy change of the H2-generation reaction in hand (AG'; [10]):

AG ' = AG0' + RT ■ In

[ NAD + ]■ PH: [NADH]H4

where A G is the Gibbs free energy at standard conditions (kJ/mol), R is the gas constant (kJ/mol-K) and T the absolute temperature (K).

In general, extreme thermophiles reach higher H2 yields than mesophiles (Table 1) [13], and also at higher temperatures the critical PH2 is higher. For instance, at a temperature of 70°C the critical PH2 is 0.173 kPa. However, this value is still well below 60 kPa, at which in practice C. saccharolyticus is still capable of producing 3.6-4.0 moles H2/mol glucose [16].

To understand this controversy, it is to be noticed that temperature is not the only factor influencing H2 generation. The AG' of the H2-producing process is also a function of the type of cofactor involved and the ratio of reduced to oxidized cofactors [43]. Each cofactor has a different formal potential, i.e., the E0 for Fdred/Fdox < NADPH/NADP < NADH/NAD [36,38,39], and unless the cofactor specificity of the involved hydrogenase is known, it is not possible to determine the thermodynamics of the system. C. saccharolyticus possesses two distinct hydrogenases, i.e., one NADH-dependent Fe-only hydrogenase (Csac_1860-1864) and one Fdred-dependent, membrane-associated NiFe hydrogenase (Csac_1540-1545) [26]. Given that the formal potential of Fdred/Fdox (E0 approx. -400 mV) is close to that of H2 (E0'H2: -414 mV) [41], the Fd-dependent hydrogenase reaction is energetically favourable up to a PH2 of 39 kPa at standard conditions. However, this calculation is based on an approximation since the actual midpoint redox potential of Fd depends on the strain and the

Figure 1 Overview of H2 generation pathways in different bacteria. In C. saccharolyticus (A), H2 is produced from NADH and Fdred, generated in the breakdown of glucose into acetate and CO2 via the EMP pathway. The H2 generation pathway in severalclostridia carrying out acetate-type fermentation (B) is different from that in C. saccharolyticus in that H2 is generated solely from Fdred. NADH (generated in the EMP pathway) is converted to Fdred via NADH:ferredoxin oxidoreductase catalyzed reaction. In Enterobacteria (C), H2 is generated from formate, which is produced in the acetate pathway through the PFL-catalyzed reaction.

temperature [44]. The actual midpoint redox potential for Fd at 70°C in C. saccharolyticus is not known, but should be in the same order of magnitude as found in other related thermophilic bacteria. From the

thermodynamic estimation, it is obvious that it is primarily the NADH-dependent Fe-only hydrogenase that is inhibited by elevated PH2. Consistently, the NADH-dependent Fe-only hydrogenase in Thermoanaerobacter

tengcongensis was downregulated at high PH2, while the Fd-dependent hydrogenase was constitutively expressed, independently of the PH2 [45].

Recently, Schut and Adams [46] characterized a novel type of Fe-only hydrogenase in Thermotoga maritima (TM1424-TM1426) that uses NADH and Fdred simultaneously. This novel bifurcating hydrogenase could therefore catalyze the unfavourable oxidation of NADH to H2 by using the exothermic oxidation of ferredoxin as a driving force. Interestingly, the Fe-only hydrogenase genes in C. saccharolyticus (Csac_1860, 1863-1864) show > 50% sequence similarities to the bifurcating hydrogenase genes in Tm. maritima (TM1424-TM1426), but it remains to be investigated whether this hydrogenase in C. saccharolyticus possesses a bifurcating function. In fact, many of the thermophiles listed in Table 1 and several mesophilic clostridia possess a Fe-only hydrogenase-encoding genes with sequence similarity to TM1424-TM1426 in Tm. maritima [46]. This observation could give a plausible explanation to the ability of these thermophiles to produce high H2 yields in well-sparged bioreactors.

The ratio of reduced to oxidized cofactors has also a significant impact on the thermodynamics of the system (Eq. 1), which was confirmed experimentally by Velt et al [43]. In C. saccharolyticus, the NADH/NAD ratio changed six folds during growth-phase transition in batch cultures [47], and consequently the value of the critical PH2 for hydrogen production will also vary with the growth state of the organism. Similar observations were reported for Clostridium cellulolyticum [48], Cl. butyricum [49] and Cl. acetobutylicum [50]. Therefore, based on the reasoning above, the thermodynamic constraint might not be an absolute parameter for determining the critical PH2 for hydrogen production.

However, the generally higher H2 yields obtained by thermophilic organisms still implies that temperature has a significant impact. An intriguing question that arises is why these thermophiles have evolved for optimized H2 production. Resolving this phenomenon would aid in designing highly efficient H2 cell factories.

5. Effect of PH2 versus dissolved H2 concentration

As discussed above, due to gaps in the knowledge on the redox system in C. saccharolyticus, the thermody-namic constraint cannot be used to estimate its tolerance to H2. For practical reasons, the PH2 in the gas phase is generally used as a measure for H2 tolerance. The critical value of PH2 (10-20 kPa) as found for C. saccharolyticus is often quoted in the literature, and is defined as the partial pressure of H2 at which lactate formation, an alternative way for reoxidizing NADH, is initiated [30]. This critical PH2 was determined in batch

cultures of C. saccharolyticus on sucrose using a closed bioreactor without sparging. However, in a similar experimental setup, but with xylose as the substrate, the critical PH2 was up to 60 kPa, upon which the metabolism shifted to lactate [16]. A possible explanation for the observed discrepancy can be based on the difference in the organism's metabolic activity on the two substrates, i.e., the volumetric H2 productivity is lower on xylose than on sucrose which results in different concentrations of dissolved H2 [16]. The variation in the observed critical PH2 values can also be a consequence of a different distribution pattern of catabolic and anabolic fluxes on the two substrates, leading to different metabolite levels that modulate lactate dehydrogenase (LDH) activity [47]. In that sense, the critical PH2 has no strict value, but will depend on the organism, the substrate and probably other environmental factors of the fermentation process. To make it more complicated, in batch cultures on glucose (5 g/L), lactate formation is triggered at the transition to the stationary phase, even though the PH2 was low (6.3 kPa) [47]. Therefore, there are obviously other factors that initiate lactate formation [47], making its use as a proper criterion for defining the critical PH2 questionable. Despite lactate being formed, growth still continues, but rather in a linear than an exponential fashion [16]. In addition, in continuous cultures of C. saccharolyticus on glucose, growth and H2 production were still observed at a PH2 of 67 kPa at a low dilution rate (0.05 h-1) [47].

Kraemer et al [51] could not find any coherent correlation between the sparging gas flow rate and H2 yield under different fermentation conditions. Due to this ambiguity, one may wonder whether PH2 is an appropriate parameter for inferring the critical H2 concentration for growth and hydrogen production. Indeed, Pauss et al [52] demonstrated in various bioreactor systems that the dissolved H2 easily supersaturates the liquid phase and its concentration is far from equilibrium with the gas phase. This can be attributed to the low solubility of H2 in water and that H2 production takes place in the liquid phase. The dissolved H2 concentration is a function of H2 productivity and the mass transfer rate [16], where the latter is a function of gas sparging rate and the stirring rate. A study with C. saccharolyticus in a pH and temperature controlled stirred tank reactor confirmed that the dissolved H2 concentration is a more indicative parameter for inhibition of H2 production [16]. The supersaturation of H2 in the liquid enacts a decline in H2 productivity via a metabolic shift to lac-tate, which may be a mechanism to steer away from exceeding the critical dissolved H2 concentration at which growth is inhibited [16]. To maintain a high productivity the dissolved H2 concentration should be kept

low through increasing the mass transfer rate in the reactor, e.g. by using an appropriate sparging gas and/or proper reactor design.

Nonetheless, since data on dissolved H2 concentrations are scarce in the literature and PH2 is usually the determined parameter, the PH2 will continue to be used for comparisons in this review.

5.1 Hydrogen tolerance and sulphur reduction

Based on thermodynamics, the heterotrophic archaeon Pyrococcus furiosus, with its growth optimum near 100° C [53], should reach a higher H2 yield at higher PH2 than that obtained with C. saccharolyticus [10]. This organism also has an unusual advantage in that its GAPDH counterpart, glyceraldehyde-3-phosphate: ferre-doxin oxidoreductase (GAPOR), generates Fdred [54], which has an exceptionally low formal potential (E'Fd100° C = -600 mV; [44]). Therefore, based only on thermodynamic constraints (Eq. 1; [41]), P. furiosus should be the least H2-inhibited anaerobe listed in Table 1[41]. Yet, it produces only 2-3 moles H2/mol hexose, it is highly sensitive to an increase in PH2 [55], and, when present, it prefers to reduce S0 instead of protons. In nature, low-PH2 environments are usually achievable for H2 producers living in symbiosis with hydrogenotrophic metha-nogens [10].

This preference for S0 can be explained by examining the physiological properties of its hydrogenases, of which P. furiosus possesses three distinct sets. It has two cytosolic NiFe-hydrogenases, which can reduce either protons to H2 or polysulphide to H2S, using NADPH as an electron donor. It also has a membrane-bound NiFe-hydrogenase, which can reduce protons to H2 using Fdred as an electron donor [51], with the unique capability of generating a proton motive force via proton translocation [56]. Moreover, it has a NiFe-containing hydrogenase complex [51], but its physiological role is partly unknown. As a third set, the organism possesses a ferredoxin:NADP oxidoreductase (or sulphide dehy-drogenase) that regulates product formation depending on the PH2 [51]. In other words, with increasing PH2, this enzyme becomes more active and decreases H2 production by transferring electrons from Fdred to either polysulphide or NADP [51]. NADPH can then be used to reduce pyruvate to alanine, catalyzed by an NADPH-dependent glutamate dehydrogenase and alanine amino-transferase [57].

S0 reduction by Thermoanaerobacter tengcongensis enhances growth, and in its absence the organism is highly sensitive to H2 and growth is strongly inhibited at PH2 above 10 kPa [45]. There are, however, Thermoa-naerobacter species that are H2-tolerant, such as the ethanol-adapted T. thermosulfurigenes [58]. This adapted

strain is able to maintain growth at 1 atm H2 by redirecting its metabolism to ethanol, but its H2 yield is not higher than 50% of the Thauer limit [58].

Members of the genus Thermotoga, which are isolated from both shallow and deep sea hydrothermal vents rich in S0 [59], are normally able to reduce either S0 or thio-sulphate [60]. The members of this genus display varying degrees of sensitivity to H2, but H2 inhibition can be generally relieved by the addition of S0, most likely as the result of a "detoxification" reaction [61]. For instance, the Thermotoga sp. strains FjSS3.B1 and FjSS. B1 are both highly sensitive to H2 and the addition of S0 can re-establish their growth [61]. Although not generally required for its growth, Tm. maritima is able to reduce S0, but does not respire it, decreasing its H2 yield by 40% [62]. In a H2-pressurized reactor (H2/CO2, 80/20%; 300 kPa), however, growth of Tm. maritima cells was not observed unless S0 was added [61]. Johnson et al [63] demonstrated that Tm. maritima was strongly inhibited by H2, which triggers the cells to enter stationary phase. Consistently, Schroder et al [64], demonstrated that PH2 levels above 2.3 kPa might be inhibitory to growth of Tm. maritima. However, since the organism was cultivated under uncontrolled conditions, other effects, such as the growth-associated drop in pH, might have contributed to growth inhibition. Although Marinitoga is closely related to Thermotoga, members of this genus can generally tolerate more H2 than Thermotoga species. For instance, M. hydrogenoto-lerans can grow at 1 atm H2 without any reduction in biomass yield, but then ethanol is formed under these conditions, which drains the electrons required for H2 production. In addition, in the presence of S0, H2 is not formed [65].

In contrast, members of the genus Caldicellulosiruptor are generally unable to reduce S0 or thiosulphate [29,62,63]. Moreover, both C. saccharolyticus and C. owensensis are capable of growing and producing H2 at PH2 levels up to 67 and 44 kPa, respectively [16,66]. Similarly, growth of C. kristjanssonii was not inhibited at PH2 levels up to50 kPa [67].

The information gathered from the literature so far, in addition to our own work, reveals that S0-reducing ther-mophiles are generally more sensitive to H2 than thermo-philes that are unable to use S0 as an electron acceptor. This conclusion supports the previously proposed correlation between the ability to reduce S0 and the sensitivity to H2 inhibition [60]. Due to inconsistencies in the experimental design for the different microorganisms studied and the lack of data on dissolved H2 concentrations, one should be aware that it is difficult to quantify H2 tolerance. In conclusion, based on this knowledge, it can be suggested to select for non-S0-reducing H2-producing

candidates and future attempts to isolate promising H2 producers should be targeting S0-poor environments.

5.2 H2 removal from the liquid

To obtain higher H2 yields and productivities, high dissolved H2 concentrations should be avoided [51]. Therefore, methods to increase the mass transfer rate of H2 from the liquid to the gas phase should be employed. Several studies have been dedicated to develop different ways for efficient removal of H2 from the liquid phase (Table 2) [31].

Currently, N2 is commonly used as a sparging gas for lab-scale H2 production. However, applying this method at an industrial scale is not cost-effective since N2 is inert, and thus difficult to remove from the effluent gas stream [11]. Instead, CO2 could be an appropriate alternative since it can be more readily separated from H2 and, as a convenience, it is a product of the fermentation process itself [11]. Nevertheless, being chemically non inert, CO2 can influence the metabolism of some microorganisms as well as the composition of the culture medium, and hence may not be viewed as an adequate universal sparging gas. In C. saccharolyticus cultures, CO2 was already shown to negatively influence growth and H2 production rate [31]. In that study, higher partial pressures of CO2 (PCO2) were found to increase the concentration of dissolved CO2, which is hydrolyzed to bicarbonate and protons. This requires the addition of larger amounts of a caustic agent to compensate for the decrease in pH, contributing to an increased osmotic pressure, which inhibits growth in C. saccharolyticus, and a higher environmental burden [31]. Methane is another interesting alternative sparging gas that was previously shown to improve the H2 yield of a mesophilic consortium by 88% [5]. However, the effect of this gas on H2 production by C. saccharolyticus has not been investigated yet.

Other strategies, such as applying reduced pressure to remove H2 and CO2 from the headspace, have been shown to efficiently increase H2 yields in Enterobacter cloacae at lab scale [68]. However, on an industrial

scale, this strategy might not be economically feasible due to high energy cost and increased contamination risk. Instead, two other alternative approaches may be pursued: i) improvement of reactor design to decrease the levels of dissolved H2 and CO2, and ii) metabolic engineering of the organism to enable it to either produce higher H2 yields at high PH2 or to withstand higher osmotic pressures.

6. Sugar transport and energy conservation

Based on its genome sequence and transcriptome analysis, C. saccharolyticus appears to rely primarily on ABC transporters for sugar uptake [23,26]. Bacterial and archaeal ABC transporters consist of five subunits, i.e., a sugar-binding protein, two transmembrane domains and two nucleotide-binding domains [69]. A common characteristic of the sugar binding protein is its ability to capture the sugar outside the cell via a cap-lock mechanism, which determines the high affinity of the transporter for the substrate. Despite the large number of ABC transporters in C. saccharolyticus [26], none of them have been characterized so far. However, based on transcriptional analysis, it has been concluded that, in C. saccharolyticus, the same transporter might translocate different sugars with varying affinities [23,26].

From a physiological perspective, ABC transporters have the disadvantage of relatively high energy demand, compared with the phosphoenol pyruvate (PEP)-dependent phosphotransferase system (PTS) (Table 3) [70]. In the latter system, one mole of the high-energy compound PEP is required for both sugar transport and subsequent phos-phorylation [70], whereas two moles of ATP are required for the same steps using an ABC transporter. The fuelling of these energy demanding, high-affinity transport systems in a strict anaerobe such as C. saccharolyticus requires an efficient energy-conserving metabolism. It can be hypothesized that one of these energy-conserving strategies is the oxidation of glucose to acetate and CO2, which results in two extra moles of ATP per mole of hexose on top of the usual ATP yield of 2 mol/mol hexose in the EMP pathway. Thus, with the conversion of glucose to two moles of

Table 2 Comparison of different sparging conditions

Sparging gas Separation Benefits Drawbacks Reference

N2 Difficult Not inhibitory Difficult to separate from H2 Expensive [10,28]

CO2 Easy Easily separated Produced in the process Increases osmolarity Inhibits H2 [10,28]

productivity

CH4 Easy Easily separated Produced in a hybrid biohydrogen/biogas No results available for C. saccharolyticus [5]

process

Under- Easy Not inhibitory Expensive at large scale [68]

pressure No dilution of the gas Risk of contamination

Cheap separation

No sparging Easy No dilution of the gas Inhibits H2 productivity [16]

Cheap separation Inhibits H2 yield

Table 3 Theoretical ATP yield (YATP/S) (mol/mol) of anaerobic glucose oxidation with different transport systems and fermentation products

Transport Fermentation product

acetate lactate ethanol butyrate butanol propionate

ABC 3 112 1 1

PTS 4 2 2 3 2 2

acetate, maximally four moles of ATP can be acquired, with the net yield being only three moles if an ABC transporter is involved (Table 3). This means that with acetate as the end product, the desired H2 production becomes advantageous for the microorganism since it serves as an electron sink in the re-oxidation of the reduced cofactors Fdred and NADH generated in the breakdown of sugars.

To investigate the presented hypothesis further, the genomes of known H2-yielding anaerobes were analyzed to evaluate whether they possess PTS- or ABC-type of sugar transport. Indeed, there is a clear correlation between high H2 yields and the use of ABC transporters (Tables 1 &4). Organisms that were able to produce high H2 yields generally possess mainly ABC-type transporters, whereas low H2-yielding bacteria utilize more PTSs for transport. This correlation between H2 yields and possession of ABC transporters is more pronounced in thermophiles. For example, the extreme thermophile Thermoanaerobacter pseudoethanolicus, which has a PTS for glucose uptake, is unable to produce more than 2 moles H2/mol hexose (101), and mainly forms ethanol as a metabolic end product instead of acetate.

Table 4 The type of transport system with respect to

growth temperature

Organism Opt T °C Transporters Reference

Enterobacter aerogenes 37 PTS [107]

Enterobacter cloacae 37 PTS [107]

Clostridium butyricum 30 PTS This study

Clostridium acetobutylicum 34 PTS [108]

Clostridium thermocellum 60 ABC [109]

C. saccharolyticus 70 ABC [26]

Thermotoga neopolitana 77 ABC [110]

Thermoanaerobacter tengcongensis 75 ABC This study

Thermoanaerobacter 70 PTS This study

pseudoethanolicus

Pyrococcus furiosus 90 ABC This study

A selection of mesophilic, thermophilic and extreme thermophilic H2-producing strains, showing their optimal growth temperature, H2 yields and type of glucose transport. The type of glucose transport assigned to each organism was either retrieved from literature or based on bioinformatic

6.1 PPi as an additional energy carrier

Another strategy to conserve energy employed by C. saccharolyticus is to utilize inorganic PPi as an additional energy carrier [71]. This strategy is widely applied by anaerobes and other organisms that can acquire only low energy outputs in their metabolism to obtain sufficient ATP [72], of which Tm. maritima [73] and various Clostridium species [72,73] are a few examples that have been studied to some extent.

The primary sources of PPi are poly-nucleic acid biosynthesis from (deoxy)nucleotide triphosphates and activation of amino acids and fatty acids for protein and lipid synthesis, respectively, which are reactions that operate close to equilibrium. Therefore, subsequent PPi hydrolysis is required for driving these reactions forward [74]. Moreover, studies on E. coli have shown that maintaining low PPi concentrations through effective PPi hydrolysis is required for rapid growth [75]. In E. coli, as in a majority of other organisms, PPi hydrolysis is catalyzed by a cytosolic inorganic pyrophosphatase (PPase), with the dissipation of the free-energy change of the bound PPi (AG0'=-21.8 kJ/mol; [76]) as heat.

C. saccharolyticus lacks a cytosolic PPase. Instead, the energy of PPi hydrolysis can be conserved, for instance through: (i) an active membrane-bound PPase employing the free-energy change of the phosphate bond hydrolysis to establish a proton motive force that could be utilized for transport of nutrients or for ATP synthesis; (ii) a PPi-dependent phosphofructokinase (PPi-PFK) in addition to the ATP-dependent one (ATP-PFK); and (iii) a PPi-dependent pyruvate phosphate dikinase (PPdK) in addition to the ADP-dependent pyruvate kinase (PYK; Figure 2) [71].

Interestingly, there are indications that the PPi-level follows the growth dynamics of C. saccharolyticus. When the cells were growing exponentially at the maximum growth rate, the PPi levels were relatively high (4 ± 2 mM), and when the growth rate decreased, the PPi levels declined concordantly. The dynamics in PPi levels were shown to be associated with the low cytoso-lic PPase activity in C. saccharolyticus [71]. Consistently, the PPi levels followed the same growth-dependent trend in Moorella thermoacetica and Cl. pasteurianum, both of which also lack a cytosolic PPase [76]. In contrast, in E. coli possessing elevated cytosolic PPase activity (0.54 U/mg cdw), the PPi levels were low (0.3 mM) and did not fluctuate during growth [76].

Unlike PPi, the ATP levels in C. saccharolyticus were very low (0.43 ± 0.07 mM) during the exponential growth phase, but increased 2 folds at the beginning of the stationary phase [71]. Interestingly, the ADP concentration was higher than that of ATP during both phases [71], which is generally considered to be a sign of starvation. Similar low ATP/ADP ratios were observed in

Glucose

Glucose

2 F6P 3 PPi--^ ^--ATP

Pi «—

Anabolism

♦ ♦ / y

/ I ' X

1,3-DPG

ATDPP <= H

PEP ** +}

Hydrogenase

PPi--^ ^--ADP 1

ATP «--^^—► ATP NADH

▼ ▼

CoA CO2

Succinate

AcCoA 8| AcP

Ethanol

Acetate

Figure 2 Proposed catabolic network in C. saccharolyticus. Glucose is transported over the membrane by an ABC transport system (1) [23,26] and oxidized to pyruvate in the EMP pathway [13,26], with the possibility that PPi can potentially replace ATP, i.e., PPi-PFK (2) instead of ATP-PFK (3), or ADP, i.e., PPDK (5) instead of PYK (6) [71]. NADH generated through the GAPDH-catalyzed reaction (4) and Fdred generated from the PFOR-catalyzed reaction (7) can donate electrons for the generation of molecular H2 catalyzed by cytosolic NADH-dependent Fe-only hydrogenase and membrane-bound Fd-dependent NiFe-hydrogenase, respectively [26]. Acetate is formed by the consecutive actions of phosphotransacetylase (PTA; 8) and acetate kinase (AK; 9), with the generation of ATP. Alternative routes for NADH reoxidation are the formation of lactate (LDH; 11), ethanol(ADH; 10) or succinate (12) [16]. The solid lines represent metabolic routes, whereas the dashed lines represent metabolite activation (+) or inhibition (-) of enzyme activities. PPi generated from anabolic reactions [71] is a strong inhibitor of both PYK and LDH activities [47,71].

Cl. acetobutylicum [77]. Nevertheless, C. saccharolyticus grew exponentially, suggesting that it relies on other energy carriers, such as PPi, that may contribute to its energy charge in addition to ATP [71].

The use of PPi as an additional energy carrier also introduces greater metabolic flexibility. In addition, it creates a stronger link between anabolism and catabo-lism, i.e., the net ATP generated in catabolic pathways is used as an energy input in biosynthetic pathways, which generates PPi that can participate in driving catabolism and generating ATP (Figure 3). In this cycle, both ATP and PPi may be key regulators of catabolic and anabolic fluxes.

6.2 Enzyme regulation

Regulation of the classical glycolysis and the flux distribution at the pyruvate node is a very complex and highly tuned process, since it is the principal provider of energy carriers and redox equivalents that need to be precisely balanced under all growth conditions. Regulation takes place at metabolite level as well as at enzyme and gene expression levels. Enzyme activities normally

are regulated via direct mass action law (concentrations of substrates or effectors) or via allosteric inhibition or activation [78]. To maintain high growth rate conditions, cells of C. saccharolyticus should obtain optimal energy gain from the substrate to fuel both anabolism and sugar transport, and thus lactate dehydrogenase (LDH) and alcohol dehydrogenase (ADH) should be kept inactive (Figure 2). Indeed, a recent batch-fermentation study has shown that during exponential growth, H2, CO2 and acetate are the only fermentation products in C. saccharolyticus [47]. In this growth phase, neither ethanol nor lactate was formed, although both LDH and ADH activities were detected in crude cell extracts at high levels. However, as the growth rate decreased during transition to the stationary phase, the metabolism was partly directed towards lactate formation. Similar growth phase-related metabolic shifts have been observed in Cl. cellulolyticum [48]. Studying the in vitro kinetics of LDH activity in C. saccharolyticus confirmed the observations of the batch experiments. It revealed that LDH activity in C. saccharolyticus is strongly regulated by the levels of the energy carriers PPi and ATP,

C-source

Biomass À

C-source

Acetate + H

Precursor metabolites

Lactate

Acetate + H

Figure 3 Schematic representation of the suggested circulation of energy carriers in catabolism and anabolism in C. saccharolyticus during exponential growth (A), and non-growth (B), and its influence on metabolite formation. During exponentialgrowth, there is a high energy demand in the cells. The formation of acetate allows maximum ATP gain and high levels of PPi secure economicaluse of ATP, including the inhibition of LDH activity and prevention of lactate formation. During non-growth, the ATP demands in the cells are reduced and LDH activity is restored due to the absence of PPi.

in addition to the NADH/NAD ratio (Figure 2) [47]. When the cells are growing at the maximum specific growth rate, PPi levels are high and ATP levels are low, keeping LDH inactive and its affinity for NADH low. It further assures that the catabolic flux is directed to acetate and H2 (Figure 2). However, as soon as the anabolic activity declines, the PPi/ATP ratio drops by an order of magnitude [71], which results in an increase in LDH activity as well as its affinity for NADH and hence lac-tate starts being formed [47].

Due to the strong control of C. saccharolyticus LDH activity at enzyme level, lactate is formed only in special cases, i.e., at elevated NADH/NAD ratios and at higher ATP levels. High NADH/NAD ratios also lead to inhibition of GAPDH activity and consequently the glycolytic flux [16,47]. Since LDH activity secures the continuation of the glycolytic flux, through diminishing the NADH/ NAD ratio, the enzyme can be considered essential for balanced growth in C. saccharolyticus. It thus might be questioned whether deleting the ldh gene would improve H2 yields during sugar fermentation. It might be a better approach to control lactate production through maintaining process conditions that promote exponential growth to keep high cellular PPi levels [47]. It is worth noting that deletion of the ldh gene in E. coli only slightly increased H2 yield and productivities [79].

Ethanol is another reduced end product that is formed during growth of C. saccharolyticus, albeit in very low quantities (Figure 2; [13,42]). Based on sequence similarities to the characterized ADH in T. ethanolicus [80], ADH in C. saccharolyticus possesses a NADPH-binding domain instead of a NADH-binding domain (Figure 2) [26]. This observation is supported by a preliminary kinetic study showing that the affinity of the ADH of C. saccharolyticus for NADPH is higher than for NADH [16], indicating that ethanol and H2 formation do not compete for the same reduced cofactor.

13C-NMR analysis of intact cells has also revealed that C. saccharolyticus is capable of reducing either pyruvate or PEP to succinate (Figure 2) in the reductive branch of its incomplete TCA cycle. However, the succinate yield is significantly lower than that of acetate or lactate under regular growth conditions and might only operate under combined elevated PH2 and PCO2 levels [31].

Understanding the regulation of the key glycolytic enzyme GAPDH in C. saccharolyticus may also contribute to a better understanding of the organism's ability to tolerate elevated PH2. In general, GAPDH is strongly regulated by the NADH/NAD ratio [81], and GAPDH in C. saccharolyticus proved to be no exception [16]. However, the enzyme in C. saccharolyticus is more resistant to increased NADH levels than GAPDH in most other related bacteria. The NADH concentration required for 50% inhibition of the enzyme in C. saccharolyticus was

0.03 mM, as compared to 0.01 mM in T. thermohydrosul-furicus (formerly known as Cl. thermohydrosulfuricum) [58] and Cl. acetobutylicum [77]. This observation would in theory have a significant impact on the organism's tolerance to H2, i.e., if GAPDH was less inhibited by NADH, higher NADH/NAD ratios could be tolerated in the cell without affecting the glycolytic flux. As discussed above, this would also render the hydrogenase reaction more energetically favourable (Eq. 1) [10]. Consistently, the ethanol-adapted T. thermohydrosulfuricus strain possesses a GAPDH that tolerates approximately twice the amount of NADH and is more tolerant to H2 than the wild-type strain [58]. Likewise, the NADH/NAD ratio in Cl. cellulyticum is significantly higher than in C. sacchar-olyticus, which is possibly due to a more relaxed inhibition of its GAPDH by NADH (50% inhibition at 0.1 mM NADH) [42,43].

7. Challenges for optimizing hydrogen production by C. saccharolyticus

C. saccharolyticus has several desirable characteristics needed for a H2 cell factory, such as its high H2 yields on a wide spectrum of carbon sources, its relatively high tolerance to elevated PH2, and its inability to reduce S0, which therefore does not interfere with its H2 production capabilities. However, the organism also lacks several properties, which should be considered before it can be used industrially.

7.1 Sensitivity to high osmolalities

Primarily, the sensitivity of C. saccharolyticus to increased osmotic pressures is a major drawback that should be addressed. The critical concentration of salts and solutes at which the growth of the organism ceases completely was estimated to be 400-425 mM [30]. Osmolalities above 0.218 osm/kg H2O were found to induce cell lysis in C. saccharolyticus, as indicated by increased protein and DNA concentrations in the culture supernatant [31]. This low osmotolerance imposes limitations on sparging the culture with CO2 and on the maximum sugar concentration in the medium [31], with the latter obviously having a negative effect on H2 productivity [30]. On the other hand, the hyperthermophiles Tm. neapolitana and P. furiosus can grow optimally in the presence of 0.46 M NaCl and 0.5 M NaCl, respectively [82,83]. These salt concentrations correspond to an additional 0.92 and 1 osm/kg H2O, respectively, in the culture media, demonstrating that these two hyperthermophiles are better protected against osmotic stress than C. sac-charolyticus. This higher osmotic tolerance is due to their ability to produce compatible solutes, or osmopro-tectants, such as b-mannosylglycerate, di-myo-insitol phosphate and glutamate [82,83]. It remains to be investigated whether C. saccharolyticus is also able to

efficiently synthesize similar solutes when exposed to osmotic stress. The low salt concentration in its natural habitat [28] may have resulted in the loss of any capability to survive in an unfavourable osmotic environment [82]. However, the presence of biosynthetic genes for some osmoprotectants, such as proline and glutamate, could open the way for directed evolution to render C. saccharolyticus more osmotolerant [31].

7.2 Low productivities

The low cell density of cultures of C. saccharolyticus and other thermophiles, is another major drawback for industrial-scale application. It results in a low volumetric H2 productivity [83], unless dialysis or cell-recycling methods are used to increase the cell mass [84]. Especially dialysis was found to increase the cell density of Pyrococcus furiosus by an order of magnitude, indicating that the presence of metabolic products prevents the increase in cell densities. In continuous cultures of C. saccharolyticus, the volumetric productivity could be enhanced by increasing the dilution rates, but this comes at the expense of the H2 yield [13,85]. The decrease in yield could be related to increased dissolved H2 concentrations resulting from higher H2 productiv-ities[16]. This can inhibit the hydrogenase activity and ultimately results in a metabolic shift to lactate. The same trade off between yield and productivity was also observed with other microorganisms. For instance, E. coli produces much lower H2 yields but its volumetric productivity is almost 100-fold higher than in C. saccharolyticus [13,86]. The cell density is about 200 times higher for E. coli [85] than for C. saccharolyticus [14], which contributes considerably to the higher volumetric productivity. The specific H2 productivity of E. coli, however, is low, which could be an undesirable consequence of the higher cell number, i.e., it enhances the H2 mass-transfer resistance [85].

7.3 Biofilm formation and reactor design

Since C. saccharolyticus exhibits a relatively high specific H 2 productivity, its volumetric production rate can potentially be enhanced through increasing its cell density [83] by, for example, inducing biofilm formation. The reactor configuration is an important factor in enhancing biofilm formation. So far, most research on C. saccharo-lyticus has been carried out in continuously stirred tank reactors (CSTR) [2,13,14,85], which do not allow for efficient biomass retention. Alternative reactors that enhance biofilm formation include trickling-bed bioreac-tors [11] and fluidized-bed systems with granules [86]. Trickling-bed bioreactors promote biofilm growth by means of packing material with a high surface area within the trickling bed. The liquid passes continuously through the filter, such that it guarantees a good liquid-gas

exchange. In the fluidized-bed system, the biofilm is also formed as granules. This reactor system increases the turbulence, thus providing an enhanced mass transfer, which potentially also could decrease the dissolved H2 concentration, and hence, improve H2 yields. It should be noted that the biofilm mode of growth also offers the surface-attached and matrix-encased bacteria a means of protection against several stressful environmental conditions [87], which could benefit an organism like C. saccharolyticus in tolerating higher osmotic pressures. Recently, another Caldicellulosiruptor sp., viz. Caldicellu-losiruptor owensensis, was shown capable of biofilm formation in both trickling-bed and fluidized-bed reactors at 70°C [88]. Moreover, the organism retained its ability to grow and produce H2 in the fluidized-bed system even in complete absence of gas sparging.

8. Conclusions

This review article has focused on C. saccharolyticus as having several desirable characteristics for efficient H2 production. This is not only due to the high growth temperature of this organism, but there are strong indications that its metabolic constitution is adapted to efficiently extract energy from carbohydrates, thereby allowing the production of H2 at yields close to the Thauer limit [14]. The energy metabolism of C. saccharolyticus, based on maximum ATP production per sugar unit and the use of PPi as an alternative energy carrier, might be correlated with the vast number of ABC transporters it employs. The efficiency of the energy metabolism is further illustrated by the modulation of LDH activity in C. saccharolyticus through the levels of the energy carriers ATP and PPi [47]; an active LDH will significantly lower the ATP production flux and thus the growth and H2 production rates, in addition to draining the electrons required for H2 production.

C. saccharolyticus can simultaneously co-utilize a wide variety of different sugars [24] and produces efficient extracellular hydrolytic enzymes, including cellulases [21]. It has a relatively high tolerance to partial hydrogen pressures that might be related to its inability to reduce S0.

The set of capabilities of C. saccharolyticus described above is the foundation to exploit this organism in a commercial process using various raw materials [89]. However, for obvious economical reasons the performance of C. saccharolyticus needs to be further improved, i.e., both high H2 yields and productivities should be obtained at relatively high PH2 [6].

Several metabolic engineering strategies can be foreseen to improve H2 yields of C. saccharolyticus beyond 3.5 mol/mol hexose, without the need for gas sparging. First, the NADH-dependent GAPDH in C. saccharolyticus could be replaced with an Fd-dependent GAPOR,

similar to the one in P. furiosus [54] making the corresponding H2-generation reaction spontaneous even at elevated PH2 [9,36]. Second, introducing the genes for the oxidative part of the PPP supplemented with an NADPH-dependent hydrogenase could allow the oxidation of one mole of hexose to one mole of acetate and four moles of CO2 [14,90]. This would in theory yield 8 mol H2/mol hexose, but would not help overcome the thermodynamic barrier.

C. saccharolyticus exhibits a considerably high specific H2 production rate compared to other H2 producers [83], but poor volumetric productivities are obtained since its maximum cell densities is in the range of 108-109 cells/mL [15]. Strategies to increase the cell density by at least an order of magnitude would be through inducing biofilm formation and/or increasing the substrate concentration. The latter requires strains with at least 5-fold increased osmotolerance, which might be obtained through evolutionary engineering. It is noteworthy that C. saccharolyti-cus possesses all the essential genes necessary for biosynthesis of compatible solutes, such as glutamate and proline [31].

As a technical approach, oversaturation of H2 in the liquid phase should be avoided to stabilize the fermentation process. This can be solved by smart reactor design and process configuration. Different membrane reactors have been developed, which are capable of reducing dissolved H2 concentrations and have a positive effect on H2 yields [91-94]. Yet, it remains to be investigated how C. saccharolyticus would perform in these reactor systems.

All in all, it is vital to understand the physiology of H2 production, which can be facilitated through applying genetic engineering and state-of-the-art 'omics' tools. However, so far, genetic protocols have been developed only for a few thermophilic hydrogen producers [95-98], but not yet for C. saccharolyticus. Omics-based technologies are increasingly applied for studying thermophilic H2 producers [25,99,100], including C. saccharolyticus [24,25]. Together with genome-wide metabolic models, now being developed for some thermophiles [101,102], the systems biology approach can eventually be applied to accelerate our understanding of the physiology of C. saccharolyticus and other thermophiles to increase their potential for process applications.

The insights in the physiology of C. saccharolyticus, as covered in this review, should contribute to better strategies for the isolation and/or engineering of future superior H2 producers. Creating a superior H2 cell factory is a quintessential step towards a sustainable biological H2 production.

9. Competing interests

The authors declare that they have no competing interests.

10. Authors' contributions

KW conceived of the study, designed and drafted the manuscript. AAZ contributed to the design and content of the review article and helped to draft the manuscript. EWJN helped to draft the manuscript. AAZ and EWJN critically revised and commented the manuscript. All authors read and approved the final manuscript.

11. Acknowledgements

AAZ acknowledges support from the Ministry of Higher Education in Egypt.

The research on biohydrogen production in our lab is financially supported

by the Commission of European Communities, Sixth Framework Program,

Priority 6, Sustainable Energy Systems (019825 HYVOLUTION) and the

Swedish Energy Agency (Energimyndigheten; 31090-1).

Received: 31 August 2010 Accepted: 22 November 2010

Published: 22 November 2010

References

1. Claassen PAM, van Lier JB, Contreras AML, van Niel EWJ, Sijtsma L, Stams AJM, de Vries SS, Weusthuis RA: Utilisation of biomass for the supply of energy carriers. Appl Microbiol Biotechnol 1999, 52:741-755.

2. de Vrije T, Bakker RR, Budde MAW, Lai MH, Mars AE, Claassen PAM: Efficient hydrogen production from the lignocellulosic energy crop Miscanthus by the extreme thermophilic bacteria Caldicellulosiruptor saccharolyticus and Thermotoga neapolitana. Biotech Biofuels 2009, 2:12.

3. Jen CJ, Chou CH, Hsu PC, Yu SJ, Chen WE, Lay JJ, Huang CC, Wen FS: Flow-FISH analysis and isolation of clostridial strains in an anaerobic semisolid bio-hydrogen producing system by hydrogenase gene target. Appl Microbiol Biotechnol 2007, 74:1126-1134.

4. Ueno Y, Otsuka S, Morimoto M: Hydrogen production from industrial wastewater by anaerobic microflora in chemostat culture. J Ferment Bioeng 1996, 82:194-197.

5. Liu D, Zeng RJ, Angelidaki I: Hydrogen and methane production from household solid waste in the two-stage fermentation process. Water Res 2006, 40:2230-2236.

6. Hallenbeck PC, Ghosh D: Advances in fermentative biohydrogen production: the way forward? Trends Biotechnol 2009, 27:287-297.

7. Kovacs KL, Maroti G, Rakhely G: A novel approach for biohydrogen production. Int J Hydrogen Energy 2006, 31:1460-1468.

8. Claassen PAM, de Vrije T: Non-thermal production of pure hydrogen from biomass: HYVOLUTION. Int J Hydrogen Energy 2006, 31:1416-1423.

9. Thauer RK, Jungermann K, Decker K: Energy conservation in chemotrophic anaerobic bacteria. Bacteriol Rev 1977, 41:100-180.

10. Stams AJM: Metabolic interactions between anaerobic bacteria in methanogenic environments. Antonie Van Leeuwenhoek 1994, 66:271-294.

11. van Groenestijn JW, Hazewinkel JHO, Nienoord M, Bussmann PJT: Energy aspects of biological hydrogen production in high rate bioreactors operated in the thermophilic temperature range. Int J Hydrogen Energy 2002, 27:1141-1147.

12. Kleerebezem R, van Loosdrecht MCM: Mixed culture biotechnology for bioenergy production. Curr Opin Biotechnol 2007, 18:207-212.

13. Kengen SWM, Goorissen HP, Verhaart M, van Niel EWJ, Claassen PAM, Stams AJM: Biological hydrogen production by anaerobic microorganisms. In Biofuels. Edited by: Soetaert W, Vandamme EJ. Chichester: John Wiley 2009:197-221.

14. de Vrije T, Mars AE, Budde MA, Lai MH, Dijkema C, de Waard P, Claassen PAM: Glycolytic pathway and hydrogen yield studies of the extreme thermophile Caldicellulosiruptor saccharolyticus. Appl Microbiol Biotechnol 2007, 74:1358-1367.

15. van Niel EWJ, Budde MAW, de Haas GG, van der Wal FJ, Claassen PAM, Stams AJM: Distinctive properties of high hydrogen producing extreme thermophiles, Caldicellulosiruptor saccharolyticus and Thermotoga elfii. Int J Hydrogen Energy 2002, 27:1391-1398.

16. Willquist K: Physiology of Caldicellulosiruptor saccharolyticus: a hydrogen cell factory. PhD thesis Lund University, Applied Microbiology; 2010.

17. Gibbs MD, Reeves RA, Farrington GK, Anderson P, Williams DP, Bergquist PL: Multidomain and multifunctional glycosyl hydrolases from the extreme thermophile Caldicellulosiruptor isolate Tok7B.1. Curr Microbiol 2000, 40:333-340.

18. Park AR, Oh DK: Effects of galactose and glucose on the hydrolysis reaction of a thermostable beta-galactosidase from Caldicellulosiruptor saccharolyticus. Appl Microbiol Biotechnol 2009, 85:1427-1435.

19. Morris DD, Gibbs MD, Ford M, Thomas J, Bergquist PL: Family 10 and 11 xylanase genes from Caldicellulosiruptor sp strain Rt69B.1. Extremophiles 1999, 3:103-111.

20. Dwivedi PP, Gibbs MD, Saul DJ, Bergquist PL: Cloning, sequencing and overexpression in Escherichia coli of a xylanase gene, xynA from the thermophilic bacterium Rt8B.4 genus Caldicellulosiruptor. Appl Microbiol Biotechnol 1996, 45:86-93.

21. Bergquist PL, Gibbs MD, Morris DD, Te'o VS, Saul DJ, Moran HW: Molecular diversity of thermophilic cellulolytic and hemicellulolytic bacteria. FEMS Microbiol Ecol 1999, 28:99-110.

22. Ivanovaa G, Rakhely G, Kovacs KL: Hydrogen production from biopolymers by Caldicellulosiruptor saccharolyticus and stabilization of the system by immobilization. Int J Hydrogen Energy 2008, 33:6953-6961.

23. Kadar Z, De Vrije T, Budde MA, Szengyel Z, Reczey K, Claassen PAM: Hydrogen production from paper sludge hydrolysate. Appl Biochem Biotechnol 2003, 105-108:557-566.

24. Van Fossen AL, Verhaart MR, Kengen SWM, Kelly RM: Carbohydrate utilization patterns for the extremely thermophilic bacterium Caldicellulosiruptor saccharolyticus reveal broad growth substrate preferences. Appl Environ Microbiol 2009, 25:7718-7724.

25. van de Werken HJG, Verhaart MRA, van Fossen AL, Willquist K, Lewis DL, Nichols JD, Goorissen HP, Mongodin EF, Nelson KE, van Niel EWJ,

Stams AJM, Ward DE, de Vos WM, van der Oost J, Kelly RM, Kengen SWM: Hydrogenomics of the extremely thermophilic bacterium Caldicellulosiruptor saccharolyticus. Appl Environ Microbiol 2008, 74:6720-6729.

26. Kataeva IA, Yang SJ, Dam P, Poole FL, Yin Y, Zhou F, Chou WC, Xu Y, Goodwin L, Sims DR, Detter JC, Hauser LJ, Westpheling J, Adams MW: Genome sequence of the anaerobic, thermophilic, and cellulolytic bacterium "Anaerocellum thermophilum" DSM 6725. J Bacteriol 2009, 191:3760-3761.

27. Yang SJ, Kataeva I, Wiegel J, Yin Y, Dam P, Xu Y, Westpheling J, Adams MWW: Reclassification of 'Anaerocellum thermophilum' as Caldicellulosiruptor bescii strain DSM 6725T sp. nov. Int J Syst Evol Microbiol 2009, 60:2011-2015.

28. Sissons CH, Sharrock KR, Daniel RM, Morgan HW: Isolation of cellulolytic anaerobic extreme thermophiles from New-Zealand thermal sites. Appl Environ Microbiol 1987, 53:832-838.

29. Bergquist PL, Gibbs MD, Saul DJ, Te'o VSJ: Molecular genetics of thermophilic bacterial genes coding for enzymes involved in cellulose and hemicellulose degradation. In Genetics, biochemistry and ecology in biodegradation of lignocellulose. Edited by: Shimada K, Hoshino S, Ohmiya K, Sakka K, Kobayashi Y, Karita S. Tokyo: Uni Publishers; 1993:276-285.

30. van Niel EWJ, Claassen PAM, Stams AJM: Substrate and product inhibition of hydrogen production by the extreme thermophile, Caldicellulosiruptor saccharolyticus. Biotechnol Bioeng 2003, 81 :255-262.

31. Willquist K, Claassen PAM, van Niel EWJ: Evaluation of the influence of CO2 on hydrogen production by Caldicellulosiruptor saccharolyticus. Int J Hydrogen Energy 2009, 34:4718-4726.

32. Rainey FA, Donnison AM, Janssen PH, Saul D, Rodrigo A, Bergquist PL, Daniel RM, Stackebrandt E, Morgan HW: Description of Caldicellulosiruptor saccharolyticus gen-nov, sp. nov. an obligately anaerobic, extremely thermophilic, cellulolytic bacterium. FEMS Microbiol Lett 1994, 120:263-266.

33. Levin DB, Carere CR, Cicek N, Sparling R: Challenges for biohydrogen production via direct lignocellulose fermentation. Int J Hydrogen Energy 2009, 34:7390-7403.

34. Panagiotopoulos IA, Bakker RR, de Vrije T, Urbaniec K, Koukios EG, Claassen PAM: Prospects of utilization of sugar beet carbohydrates for biological hydrogen production in the EU. J Clean Prod 2010, 18:S9-S14.

35. Ivanova G, Rakhely G, Kovacs KL: Thermophilic biohydrogen production from energy plants by Caldicellulosiruptor saccharolyticus and comparison with related studies. Int J Hydrogen Energy 2009, 34:3659-3670.

36. Cantarel BL, Coutinho PM, Rancurel C, Bernard T, Lombard V, Henrissat B: The Carbohydrate-Active EnZymes database (CAZy): an expert resource for Glycogenomics. Nucleic Acids Research 2009, 37:D233-D238.

37. Uyar B, Eroglu I, Yucel M, Gunduz U: Photofermentative hydrogen production from volatile fatty acids present in dark fermentation effluents. Int J Hydrogen Energy 2009, 34:4517-4523.

38. Ueno Y, Fukui H, Goto M: Operation of a two-stage fermentation process producing hydrogen and methane from organic waste. Environ Sci Technol 2007, 41:1413-1419.

39. Hallenbeck PC: Fundamentals of the fermentative production of hydrogen. Water Sci Technol 2005, 52:21-29.

40. Akhtar MK, Jones PR: Construction of a synthetic YdbK-dependent pyruvate:H2 pathway in Escherichia coli BL21(DE3). Metab Eng 2009, 11:139-147.

41. Angenent LT, Karim K, Al-Dahhan MH, Domiguez-Espinosa R: Production of bioenergy and biochemicals from industrial and agricultural wastewater. Trends Biotechnol 2004, 22:477-485.

42. Kraemer JT, Bagley DM: Supersaturation of dissolved H2 and CO2 during fermentative hydrogen production with N2 sparging. Biotechnol Lett 2006, 28:1485-1491.

43. Velt A, Kallm AM, Mizutani T, Jones PR: Constructing and testing the thermodynamic limits of synthetic NAD(P)H:H2 pathways. Microbiol Biotechnol 2008, 1 :382-394.

44. Smith ET, Blamey JM, Zhou ZH, Adams MWW: A variable-temperature direct electrochemical study of metalloproteins from hyperthermophilic microorganisms involved in hydrogen production from pyruvate. Biochemistry 1995, 34:7161-7169.

45. Soboh B, Linder D, Hedderich R: A multisubunit membrane-bound [NiFe] hydrogenase and an NADH-dependent Fe-only hydrogenase in the fermenting bacterium Thermoanaerobacter tengcongensis. Microbiology 2004, 150:2451-2463.

46. Schut GJ, Adams MWW: The iron-hydrogenase of Thermotoga maritima utilizes ferredoxin and NADH synergistically: a new perspective on anaerobic hydrogen production. J Bacteriol 2009, 191:4451-4457.

47. Willquist K, van Niel EWJ: Lactate formation in Caldicellulosiruptor saccharolyticus is regulated by the energy carriers pyrophosphate and ATP. Metab Eng 2010, 12:282-290.

48. Payot S, Guedon E, Gelhaye E, Petitdemange H: Induction of lactate production associated with a decrease in NADH cell content enables growth resumption of Clostridium cellulolyticum in batch cultures on cellobiose. Res Microbiol 1999, 150:465-473.

49. Abbad Andaloussi S, Durr C, Raval G, Petitdemange H: Carbon and electron flow in Clostridium butyricum grown in chemostat culture on glycerol and on glucose. Microbiology 1996, 142:1149-1158.

50. Meyer CL, Papoutsakis ET: Increased Levels of ATP and NADH are associated with increased solvent production in continuous cultures of Clostridium acetobutylicum. Appl Microbiol Biotechnol 1989, 30:450-459.

51. Kraemer JT, Bagley DM: Improving the yield from fermentative hydrogen production. Biotechnol Lett 2007, 29:685-695.

52. Pauss A, Andre G, Perrier M, Guiot SR: Liquid-to-gas mass transfer in anaerobic processes: inevitable transfer limitations of methane and hydrogen in the biomethanation process. Appl Environ Microbiol 1990, 56:1636-1644.

53. Fiala G, Stetter KO: Pyrococcus furiosus sp-nov represents a novel genus of marine heterotrophic archaebacteria growing optimally at 100 degrees C. Arch Microbiol 1986, 145:56-61.

54. Mukund S, Adams MWW: Glyceraldehyde-3-phosphate ferredoxin oxidoreductase, a novel tungsten-containing enzyme with a potential glycolytic role in the hyperthermophilic archaeon Pyrococcus furiosus. J Biol Chem 1995, 270:8389-8392.

55. Kengen SWM, Stams AJM: Growth and energy conservation in batch cultures of Pyrococcus furiosus. FEMS Microbiol Lett 1994, 117:305-309.

56. Sapra R, Bagramyan K, Adams MWW: A simple energy-conserving system: proton reduction coupled to proton translocation. Proc Natl Acad Sci USA 2003, 100:7545-7550.

57. Kengen SWM, Stams AJM: Formation of L-alanine as a reduced end-product in carbohydrate fermentation by the hyperthermophilic archaeon Pyrococcus furiosus. Arch Microbiol 1994, 161:168-175.

58. Lovitt RW, Shen GJ, Zeikus JG: Ethanol production by thermophilic bacteria - biochemical basis for ethanol and hydrogen tolerance in Clostridium thermohydrosulfuricum. J Bacteriol 1988, 170:2809-2815.

Adams MWW: The metabolism of hydrogen by extremely thermophilic, 81.

sulfur-dependent bacteria. FEMS Microbiol Rev 1990, 75:219-237.

Ravot G, Ollivier B, Fardeau ML, Patel BKC, Andrews KT, Magot M, Garcia JL:

L-Alanine production from glucose fermentation by hyperthermophilic

members of the domains Bacteria and Archaea: A remnant of an 82.

ancestral metabolism? Appl Environ Microbiol 1996, 62:2657-2659.

Janssen PH, Morgan HW: Heterotrophic sulfur reduction by Thermotoga 83.

sp strain Fjss3.B1. FEMS Microbiol Lett 1992, 96:213-218.

Huber R, Langworthy TA, Konig H, Thomm M, Woese CR, Sleytr UB,

Stetter KO: Thermotoga maritima sp. nov. represents a new genus of 84.

unique extremely thermophilic eubacteria growing up to 90 degrees

Celcius. Arch Microbiol 1986, 144:324-333. 85.

Johnson MR, Conners SB, Montero CI, Chou CJ, Shockley KR, Kelly RM: The

Thermotoga maritima phenotype is impacted by syntrophic interaction

with Methanococcus jannaschii in hyperthermophilic coculture. Appl

Environ Microbiol 2006, 72:811-818. 86.

Schröder C, Selig M, Schönheit P: Glucose fermentation to acetate, CO2

and H2 in the anaerobic hyperthermophilic eubacterium Thermotoga

maritima - Involvement of the Embden-Meyerhof Pathway. Arch Microbiol

1994, 161:460-470. 87.

Postec A, Le Breton C, Fardeau ML, Lesongeur FO, Pignet P, Querellou J,

Ollivier B, Godfroy A: Marinitoga hydrogenitolerans sp nov., a novel 88.

member of the order Thermotogales isolated from a black smoker

chimney on the Mid-Atlantic Ridge. Int J Syst Evolution Microbiol 2005,

55:1217-1221. 89.

Zeidan AA, van Niel EWJ: A quantitative analysis of hydrogen production

efficiency of the extreme thermophile Caldicellulosiruptor owensensis 90.

OLT. Int J Hydrogen Energy 2010, 35:1128-1137.

Bredholt S, Sonne-Hansen J, Nielsen P, Mathrani IM, Ahring BK:

Caldicellulosiruptor kristjanssonii sp nov., a cellulolytic extremely

thermophilic, anaerobic bacterium. Int J Syst Bacteriol 1999, 49:991-996. 91.

Mandal B, Nath K, Das D: Improvement of biohydrogen production under

decreased partial pressure of H2 by Enterobacter cloacae. Biotechnol Lett

2006, 28:831-835. 92.

Jones PM, George AM: The ABC transporter structure and mechanism:

perspectives on recent research. Cell Molec Life Sciences 2004, 61:682-699.

Linton KJ, Higgins CF: Structure and function of ABC transporters: the 93.

ATP switch provides flexible control. Pflugers Arch - Eur J Physiol 2007,

453:555-567.

Bielen AAM, Willquist K, Engman J, van der Oost J, van Niel EWJ, 94.

Kengen SWM: Pyrophosphate as a central energy carrier in the hydrogen-producing extremely thermophilic Caldicellulosiruptor saccharolyticus. FEMS Microbiol Lett 2010, 307:48-54. 95.

Mertens E: Pyrophosphate-dependent phosphofructokinase, an anaerobic glycolytic enzyme. FEBS Lett 1991, 285:1-5.

Ding YR, Ronimus RS, Morgan HW: Thermotoga maritima 96.

phosphofructokinases: expression and characterization of two unique enzymes. J Bacteriol 2001, 183:791-794.

Heinonen JK: Biological role of inorganic pyrophosphate Boston/Dordrecht/ London: Kluwer Academic Publishers; 2001. 97.

Chen J, Brevet A, Fromant M, Leveque F, Schmitter JM, Blanquet S, Plateau P: Pyrophosphatase is essential for growth of Esherichia coli. J

Bacteriol 1990, 172:5686-5689.

Heinonen JK, Drake HL: Comparative assessment of inorganic 98.

pyrophosphate and pyrophosphatase levels of Escherichia coli, Clostridium pasteurianum and Clostridium thermoaceticum. FEMS Microbiol 99. Lett 1988, 52:205-208.

Girbal L, Soucaille P: Regulation of Clostridium acetobutylicum metabolism as revealed by mixed-substrate steady-state continuous cultures - role of NADH/NAD ratio and ATP Pool. J Bacteriol 1994, 176:6433-6438.

Cornish Bowden A: Fundamentals of Enzyme kinetics. 3 edition. Marseilles: 100.

Portland Press; 2004.

Sode K, Watanabe M, Makimoto H, Tomiyama M: Construction and characterization of fermentative lactate dehydrogenase Escherichia coli mutant and its potential for bacterial hydrogen production. Appl 101.

Biochem Biotechnol 1999, 77-9:317-323.

Burdette D, Zeikus JG: Purification of acetaldehyde dehydrogenase and alcohol dehydrogenases from Thermoanaerobacter ethanolicus 39e and characterization of the secondary alcohol dehydrogenase (2-segrees 102.

ADH) as a bifunctional alcohol dehydrogenase acetyl-CoA reductive thioesterase. Biochemical J 1994, 302:163-170.

Garrigues C, Loubiere P, Lindley ND, Cocaign-Bousquet M: Control of the shift from homolactic acid to mixed-acid fermentation in Lactococcus lactis: predominant role of the NADH/NAD+ ratio. J Bacteriol 1997, 179:5282-5287.

Santos H, da Costa MS: Compatible solutes of organisms that live in hot saline environments. Environ Microbiol 2002, 4:501-509. Chou CJ, Jenney FE Jr, Adams MWW, Kelly RM: Hydrogenesis in hyperthermophilic microorganisms: implications for biofuels. Metab Eng 2008, 10:394-404.

Holst O, Manelius A, Krahe M, Märkl H, Raven N, Sharp R: Thermophiles and fermentation technology. Comp BiochemPhysiol 1997, 1 18:415-422. Yoshida A, Nishimura T, Kawaguchi H, Inui M, Yukawa H: Enhanced hydrogen production from formic acid by formate hydrogen lyase-overexpressing Escherichia coli strains. Appl Environ Microbiol 2006, 72:1716-1716.

Kotsopoulos TA, Zeng RJ, Angelidaki I: Biohydrogen production in granular up-flow anaerobic sludge blanket (UASB) reactors with mixed cultures under hyper-thermophilic temperature (70 degrees C).

Biotechnol Bioeng 2006, 94:296-302.

Flemming HC: Biofilms and environmental protection. Water Sci Technol 1993, 27:1-10.

Peintner C, Zeidan AA, Schnitzhofer W: Bioreactor systems for thermophilic fermentative hydrogen production: evaluation and comparison of appropriate systems. J Cleaner Prod . Lynd LR, van Zyl WH, McBride JE, Laser M: Consolidated bioprocessing of cellulosic biomass: an update. Curr Opin Biotechnol 2005, 16:577-583. Verhaart MRA, Bielen AAM, van der Oost J, Stams AJM, Kengen SWM: Hydrogen production by hyperthermophilic and extremely thermophilic bacteria and archaea: mechanisms for reductant disposal. EnvironTechnol 2010, 31:993-1003.

Tanisho S, Suzuki Y, Wakao N: Fermentative hydrogen evolution by Enterobacter aerogenes strain E-82005. Int J Hydrogen Energy 1987, 12:623-627.

Kumar N, Das D: Continuous hydrogen production by immobilized Enterobacter cloacae IIT-BT 08 using lignocellulosic materials as solid matrices. Enzyme Microbiol Technol 2001, 29:280-287. Kataoka N, Miya A, Kiriyama K: Studies on hydrogen production by continuous culture system of hydrogen-producing anaerobic bacteria. Water Sci Technol 1997, 36:41-47.

Chin HL, Chen ZS, Chou CP: Fedbatch operation using Clostridium acetobutylicum suspension culture as biocatalyst for enhancing hydrogen production. Biotechnol Prog 2003, 19:383-388. Peng H, Fu B, Mao Z, Shao W: Electrotransformation of Thermoanaerobacter ethanolicus JW200. Biotechnol Lett 2006, 28:1913-1917.

Sato T, Fukui T, Atomi H, Imanaka T: Improved and versatile transformation system allowing multiple genetic manipulations of the hyperthermophilic archaeon Thermococcus kodakaraensis. Appl Environ Microbiol 2005, 71 :3889-3899.

Santangelo TJ, Cubonova L, Reeve JN: Shuttle vector expression in Thermococcus kodakaraensis: contributions of cis elements to protein synthesis in a hyperthermophilic archaeon. Appl Environ Microbiol 2008, 74:3099-3104.

Tyurin MV, Desai SG, Lynd LR: Electrotransformation of Clostridium thermocellum. Appl Environ Microbiol 2004, 70:883-890. Conners SB, Montero CI, Comfort DA, Shockley KR, Johnson MR, Chhabra SR, Kelly RM: An expression-driven approach to the prediction of carbohydrate transport and utilization regulons in the hyperthermophilic bacterium Thermotoga maritima. J Bacteriol 2005, 187:7267-7282.

Wang J, Xue Y, Feng X, Li X, Wang H, Li W, Zhao C, Cheng X, Ma Y, Zhou P, Yin J, Bhatnagar A, Wang R, Liu S: An analysis of the proteomic profile for Thermoanaerobacter tengcongensis under optimal culture conditions.

Proteomics 2004, 4:136-150.

Zhang Y, Thiele I, Weekes D, Li Z, Jaroszewski L, Ginalski K, Deacon AM, Wooley J, Lesley SA, Wilson IA, Palsson B, Osterman A, Godzik A: Three-dimensional structural view of the central metabolic network of Thermotoga maritima. Science 2009, 325:1544-1549. Roberts SB, Gowen CM, Brooks JP, Fong SS: Genome-scale metabolic analysis of Clostridium thermocellum for bioethanol production. BMC Syst Biol 2010, 4:31.

103. Bothun GD, Knutson BL, Berberich JA, Strobel HJ, Nokes SE: Metabolic selectivity and growth of Clostridium thermocellum in continuous culture under elevated hydrostatic pressure. Appl Microbiol Biotechnol 2004, 65:149-157.

104. Munro SA, Zinder SH, Walker LP: The fermentation stoichiometry of Thermotoga neapolitana and influence of temperature, oxygen, and pH on hydrogen production. Biotechnol Prog 2009, 25:1035-1042.

105. Hild HM, Stuckey DC, Leak DJ: Effect of nutrient limitation on product formation during continuous fermentation of xylose with Thermoanaerobacter ethanolicus JW200 Fe(7). Appl Microbiol Biotechnol 2003, 60:679-686.

106. Kanai T, Imanaka H, Nakajima A, Uwamori K, Omori Y, Fukui T, Atomi H, Imanaka T: Continuous hydrogen production by the hyperthermophilic archaeon, Thermococcus kodakaraensis KOD1. J Biotechnol 2005, 116:271-282.

107. de Souza AM, Sutherland IW: Exopolysaccharide and storage polymer production in Enterobacter aerogenes type-8 strains. J Appl Bacteriol 1994, 76:463-468.

108. Hutkins RW, Kashket ER: Phosphotransferase activity in Clostridium acetobutylicum from acidogenic and solventogenic phases of growth.

Appl Environ Microbiol 1986, 51:1121-1123.

109. Hernandez PE: Transport of D-glucose in Clostridium thermocellum ATCC-27405. J Gen Appl Microbiol 1982, 28:469-477.

110. Galperin MY, Noll KM, Romano AH: The glucose transport system of the hyperthermophilic anaerobic bacterium Thermotoga neapolitana. Appl Environ Microbiol 1996, 62:2915-2918.

doi:10.1186/1475-2859-9-89

Cite this article as: Willquist et al.: Physiological characteristics of the extreme thermophile Caldicellulosiruptor saccharolyticus: an efficient hydrogen cell factory. Microbial Cell Factories 2010 9:89.

Submit your next manuscript to BioMed Central and take full advantage of:

• Convenient online submission

• Thorough peer review

• No space constraints or color figure charges

• Immediate publication on acceptance

• Inclusion in PubMed, CAS, Scopus and Google Scholar

• Research which is freely available for redistribution

Submit your manuscript at fpntral

www.biomedcentral.com/submit v-enudi