Scholarly article on topic 'Purification and characterization of endo β-1,4-d-glucanase from Trichoderma harzianum strain HZN11 and its application in production of bioethanol from sweet sorghum bagasse'

Purification and characterization of endo β-1,4-d-glucanase from Trichoderma harzianum strain HZN11 and its application in production of bioethanol from sweet sorghum bagasse Academic research paper on "Agricultural biotechnology"

Share paper
Academic journal
3 Biotech
OECD Field of science

Academic research paper on topic "Purification and characterization of endo β-1,4-d-glucanase from Trichoderma harzianum strain HZN11 and its application in production of bioethanol from sweet sorghum bagasse"

3 Biotech (2016)6:101

DOI 10.1007/s13205-016-0421-y CrossMark


Purification and characterization of endo b-1,4-D-glucanase from Trichoderma harzianum strain HZN11 and its application in production of bioethanol from sweet sorghum bagasse

Zabin K. Bagewadi1 • Sikandar I. Mulla1 • Harichandra Z. Ninnekar1

Received: 15 January 2016/Accepted: 27 March 2016

© The Author(s) 2016. This article is published with open access at

Abstract An acidophilic-solvent-thermostable endo b-1,4-D-glucanase produced from a potential Trichoderma harzianum strain HZN11 was purified to homogeneity by DEAE-Sepharose and Sephadex G-100 chromatography with 33.12 fold purification with specific activity of 66.25 U/mg and molecular mass of *55 kDa. The optimum temperature and pH were 60 °C and 5.5 retaining 76 and 85 % of activity after 3 h, respectively. It showed stability between pH 4.5-6.0 and temperature between 50-70 °C indicating thermostability. Endo b-1,4-D-glucanase was activated by Ca2? and Mg2? but inhibited by Hg2?, Pb2? and Cd2?. The effect of thiol reagents, metal chelators, oxidizing agents and surfactants on enzyme activity has been studied. Purified endo b-1,4-D-glucanase exhibited highest specificity towards carboxymethyl cellulose. Kinetic analysis showed the Km, Vmax and Ki (cellobiose inhibitor) of 2.5 mg/mL, 83.75 U/mg and 0.066 M, respectively. The storage stability of purified endo b-1,4-D-glucanase showed a loss of mere 13 % over a period of 60 days. The hydrolysis efficiency of purified endo b-1,4-D-glucanase mixed with cocktail was demonstrated over commercial enzyme. Optimized enzymatic hydrolysis of sweet sorghum and sugarcane bagasse released 5.2 g/g (36 h) and 6.8 g/g (48 h) of reducing sugars, respectively. Separate hydrolysis and fermentation of sweet sorghum bagasse yielded 4.3 g/L bioethanol (16 h) confirmed by gas

Electronic supplementary material The online version of this article (doi:10.1007/s13205-016-0421-y) contains supplementary material, which is available to authorized users.

& Harichandra Z. Ninnekar

1 Department of Biochemistry, Karnatak University, Dharwad 580 003, Karnataka, India

Published online: 12 April 2016

chromatography-mass spectrometry (GC-MS). Morphological and structural changes were assessed by scanning electron microscopy (SEM) and Fourier transform infrared spectroscopy. Elemental analysis was carried out by SEM equipped with energy dispersive X-ray technique. These unique properties prove the potentiality of enzyme for biomass conversion to biofuel and other industrial applications.

Keywords Endo b-1,4-D-glucanase • Trichoderma harzianum strain HZN11 • Purification • Characterization • Enzymatic hydrolysis • Bioethanol


In the current scenario, the major concerns are towards the diminishing of fossil fuels which have forced the energy industries and researchers to develop alternatives to the existing fuels (Bentsen and Felby 2012). One of the attractive sustainable substitutes is the microbial production of bioethanol from lignocellulosic wastes as it is cost-effective and renewable (Ren et al. 2009). Plant biomass constitute of cellulose which is the major organic polysaccharide found in the biosphere (Bhat and Bhat 1997) and is renewable. Biodegradation of plant based biomass requires cellulose and hemicellulose saccharifying enzymes. For example, cellulases participate in sacchari-fication of biomass for bioethanol production (Dhillon et al. 2011), by mainly acting on b-1,4-glycosidic bonds of cellulose. Cellulolytic enzymes have been classified as: endoglucanase (endo-1,4-D-glucanase, EG), cellobiohy-drolase (exo-1,4-D-glucanase, CBH) and glucosidase (1,4-D-glucosidase, BG) (Saha 2004), which have been shown to act synergistically for effective degradation (Lynd et al.

^j^dlxLc dLLcJI cujzlo A\ 0

^GT^ig^ H Springer

2002) whereas xylanases (1,4-p-D-xylanohydrolase) hydrolyze xylan, a major component of hemicellulose (Zhang et al. 2011). The fungal endoglucanases finds its applications in biomass bioconversions, pulp and paper, textile, detergents, starch processing, grain alcohol fermentation, brewery, wine making, extraction of fruit and vegetable juices (Karmakar and Ray 2011; Kuhad et al.

2011). These applications certainly require endoglucanases with industrial attributes like thermostability, stability at varying pH, substrate specificities (Bhat 2000), solvent tolerant, detergent compatibility, chemical stability, etc. Solid state fermentation (SSF) for cellulase production is an advantageous process as it reduces the capital investment with easy operating conditions (Pandey et al. 1999). Cellulose saccharification can be carried out by separate hydrolysis and fermentation (SHF) process with an ease of optimizing the enzymatic hydrolysis conditions (Zhu et al. 2012) for ethanol production. Ethanol quantification can be achieved by employing methods like GC-MS. Desirable for better specificity, few mass spectro-metric (MS) methods for ethanol analysis have been reported (Tiscione et al. 2011). Insights of molecular level changes and functional groups in the lignocellu-losic material at various fermentation steps could be studied by employing FTIR (Adapa et al. 2011; Sim et al.

2012), morphological changes by SEM and substrate elemental analysis by higher throughput techniques like SEM equipped with EDX technique.

Keeping in view the industrial applications of the endo p-1,4-D-glucanase, this study was carried out to purify and characterize a novel endo p-1,4-D-glucanase from Tricho-derma harzianum strain HZN11. Enzymatic hydrolysis and ethanol fermentation was successfully achieved. Further, sweet sorghum bagasse was molecularly characterized with techniques like FTIR, SEM and SEM/EDX.

Materials and methods Chemicals, substrate and culture

All the chemicals and media components used were procured from HiMedia, Sigma-Aldrich (USA) and Merck (USA). Sweet sorghum stalks were collected from University of agricultural sciences, Dharwad. Saccha-romyces cerevisiae NCIM 3594 was procured from National Collection of Industrial Microorganisms (NCIM).

Fungal strain and production of endo b-1,4-D-glucanase

Trichoderma harzianum strain HZN11 previously isolated from forest soil was identified based on 18S rDNA

¿1 Snrinopr

KAcsToAoUiq r^QjiU ^ springer

sequencing (data was not shown). The nucleotide sequence of the strain was deposited to NCBI (National Center for Biotechnology Information) GenBank with accession number KP050786. The newly isolated Trichoderma harzianum strain HZN11 is maintained at the Department of Biochemistry, Karnatak University, Dharwad on potato dextrose agar (PDA) enriched with carboxymethyl cellulose (CMC) at 4 °C. Endo p-1,4-D-glucanase was produced by Trichoderma harzianum strain HZN11 in SSF using alkali pretreated sweet sorghum bagasse as substrate. SSF was carried out in 250 mL Erlenmeyer flasks containing 10 g of pretreated substrate in Mandels-Weber medium containing (g/L) urea 0.3; ammonium sulfate 1.4; KH2PO4 0.3; CaCl2 0.3; MgSO4.7H2O 0.3; protease peptone 1.0; lactose 10; and (mg/L) FeSO4.7H2O 5.0; MnSO4.7H2O 1.6; ZnSO4.7H2O 1.4; CoCl2 2; Tween-80 0.1 %; and pH 6 with 70 % moisture content. Sterilized flasks were inoculated with 4 mL spore suspension and incubated at 35 °C under static condition for 7 days. The crude enzyme was extracted with 50 mM sodium acetate buffer, pH 6 with 1:2 solid to liquid ratio under shaking (150 rpm) at 35 °C for 30 min, followed by filtration through muslin cloth. The filtrate was centrifuged at 8000 rpm for 20 min at 4 °C. The clear supernatant was used as crude enzyme for purification.

Enzyme assay and protein determination

Endo p-1,4-D-glucanase hydrolyzes CMC to produce free carboxymethyl glucose units. Endo p-1,4-D-glucanase activity was estimated using CMC as substrate under standard conditions according to Standard International Union of Pure and Applied Chemistry (IUPAC) method described by Ghose (1987). The reducing sugars released from the reaction were determined according to Miller (1959) by dinitrosalicylic acid (DNS) method. In the above assay, one unit (U) of enzyme was defined as the amount of enzyme that released 1 imol of the glucose per minute under standard assay conditions (30 min incubation at 50 °C with 50 mM acetate buffer pH 6.0). The concentrations of soluble proteins were estimated according to Lowry et al. (1951) using bovine serum albumin (BSA) as the standard.

Purification of endo b-1,4-D-glucanase and molecular mass determination

Endo p-1,4-D-glucanase produced from sweet sorghum bagasse by Trichoderma harzianum strain HZN11 was subjected for purification. The cell debris was removed by vacuum filtration (Millipore India Ltd.) and the enzyme protein was subjected to fractionation by (NH4)2SO4 (70 % w/v). The precipitate was centrifuged at 8000 rpm for

15 min at 4 °C. Enzyme was resuspended in a minimum volume of 50 mM sodium acetate buffer (pH 6.0) and dialyzed against the same buffer for 6 h at 4 °C and lyo-philized. Total proteins and endo ß-1,4-D-glucanase activity of partially purified fraction were determined before and after dialysis. Endo ß-1,4-D-glucanase was further purified by column chromatography. The lyophilized enzyme was dissolved in 50 mM sodium acetate buffer (pH 6.0). The enzyme protein was loaded onto DEAE-Sepharose column (40 x 2 cm) pre-equilibrated with 50 mM sodium acetate buffer (pH 6.0). The flow rate was maintained at 1 mL/min and eluted with gradient of 0.1-1 M NaCl. The pooled fractions were dialyzed and lyophilized. The fractions were re-dissolved in buffer and loaded onto the Sephadex G-100 column (30 x 2 cm) pre-equilibrated and eluted with 50 mM sodium acetate buffer (pH 6.0) at a flow rate of 0.5 mL/min. The fractions were analyzed for proteins by A280 method and endo ß-1,4-D-glucanase activities were determined. The resulting concentrated active endo ß-1,4-D-glucanase fractions were pooled and used for further characterization (Bakare et al. 2005). The apparent molecular weight of the purified endo ß-1,4-D-glucanase was determined by sodium dedocylsulphate polyacry-lamide gel electrophoresis (SDS-PAGE) with protein molecular weight ladder [lysozyme (14.3 kDa), ß-lac-toglobulin (20 kDa), carbonic anhydrase (29 kDa), ovalbumin (43 kDa), bovine serum albumin (66 kDa) and phosphorylase B (97.4 kDa) run along with sample], according to the method described by Laemmli (1970). Protein bands were visualized by staining with coomassie brilliant blue R-250.

bromosuccinimide, dimethyl sulfoxide (DMSO), iodoac-etamide, p-chloromercuribenzoate (p-CMB) and 1,10-phenanthroline, at various concentrations (1-10 mM). Relative activities of endo p-1,4-D-glucanase in the presence of various detergents like sodium dodecyl sulfate (SDS), sodium tetraborate, and commercial detergents (Tide, Ariel and Surf Excel), surfactants like tween-20, tween-40, tween-80 and triton X-100 and oxidizing agents like sodium perborate, sodium hypochlorite and hydrogen peroxide at varying concentrations (0.1-1 %) were determined. Endo p-1,4-D-glucanase stability in the presence of various organic solvents like glycerol, ethanol, methanol, acetone, formic acid, propanol, petroleum ether, iso-propanol, benzene, cyclohexane, hexane, butanol and toluene at different concentrations (10-30 %) were evaluated (control was 100 %). Substrate specificity of endo p-1,4-D-glucanase was tested against variety of substrates like 1 % microcystalline cellulose, CMC, chitin, cellobiose, starch, filter paper, PNP-a-galactopyranoside, PNP-glu-copyranoside, PNP-cellobioside, brichwood xylan and oat spelt xylan. Endo p-1,4-D-glucanase kinetics with CMC concentration range of 2.5-30 mg/mL was studied and kinetic parameters Km and Vmax were determined by linear transformations of the Michaelis-Menten model to Line-weaver-Burk. Inhibition of endo p-1,4-D-glucanase with cellobiose was studied at 5 mM and 10 mM and inhibition constant Ki were determined by Lineweaver-Burk plot. The storage stability of the purified endo p-1,4-D-glucanase was monitored for 60 days.

Enzymatic hydrolysis and ethanol fermentation

Characterization of purified endo b-1,4-D-glucanase

Optimum pH of the purified endo p-1,4-D-glucanase was determined by incubating the enzyme at different pH ranging from pH 3-11 using 0.1 M buffers of sodium citrate (pH 3-4.5), sodium acetate (pH 5-6), sodium phosphate (pH 6.5-7.5), Tris-HCl (pH 8.0-9.5), and gly-cine-NaOH (pH 10.0-11.0). The stability of pH was determined at optimum range of pH 5-6 for 3 h and the relative activity was calculated. Optimum temperature was evaluated in range of 20-85 °C and the thermo stability of endo p-1,4-D-glucanase was assessed between optimum temperature ranges of 50-65 °C for 3 h at pH 5.5 by measuring the relative activity. Effect of various metal ions like Co21, Zn21, Ca21, Mg21, K1, Na1, Cu21, Hg21, Fe21, Pb21, Ni21, Mn21 and Cd21 was determined at different concentrations (1-10 mM). Endo p-1,4-D-glu-canase relative activity was evaluated in the presence of various additives like dithiothreitol (DTT), p-mercap-toethanol, ethylene diamine tetra acetic acid (EDTA), urea, phenyl methyl sulphonyl fluoride (PMSF), N-

Enzymatic hydrolysis of untreated and alkali pretreated sweet sorghum bagasse and sugarcane bagasse was studied using purified endo p-1,4-D-glucanase (53 U/g) mixed with crude multi-enzyme cocktail (exoglucanase 15 U/g, filter paper activity (FP) 15 U/g, cellobiase 18 U/g, xylanase 1740 U/g and p-glucosidase 13 U/g) produced by Tricho-derma harzianum strain HZN11 from sweet sorghum bagasse and commercial cellulase from Trichoderma sps. (9 FP U/mL) individually. Reaction constituted of 2 % substrate in 50 mM sodium acetate buffer pH 5.5, 0.1 % tween-40 and filter sterilized enzyme in a volume of 30 mL incubated at 40 °C at 150 rpm. The reaction was fortified with 0.005 % sodium azide. Samples were withdrawn, centrifuged at 8000 rpm for 15 min and the clear super-natants were analyzed for reducing sugars according to the method described by Miller (1959). Controls were kept for each reaction with heat-inactivated enzyme. Parameters such as hydrolysis time (12-72 h) and temperature (40-60 °C) for enzymatic hydrolysis of alkali pretreated sweet sorghum bagasse and sugarcane bagasse was optimized. SHF experiments were designed in which

¿1 Snrinopr

KAcsTiuiUi, ^wj ^ springer

hydrolyzates of sweet sorghum bagasse were collected and centrifuged at 8000 rpm for 15 min. The supernatant containing reducing sugars was transferred to serum bottles for fermentation process with pH maintained to 7 by 1 N NaOH. Glucose fermenting yeast, Saccharomyces cere-visiae NCIM 3594 was inoculated and incubated at 30 °C for 72 h under shaking at 120 rpm. Aliquots were withdrawn at different time intervals for the estimation of ethanol, reducing sugars and biomass.

Analytical methods

The SHF aliquot samples were filtered through 0.2 mm membrane filters for the analysis of ethanol by GC-MS (Shi-madzuQP2010 Plus) equipped with an autosampler. GC-MS accelerates ethanol analysis with its simultaneous separation and identification. GC-MS was equipped with quadruple mass filter Rtx-5MS capillary column (30 m x 0.25 mm), scan interval 0.5 s and mass range 40-500 m/z. The column temperature was maintained at 50 °C for 1 min, and then ramped with 20 °C increase per min to a final temperature at 280 °C for 14.5 min and the injector temperature was kept at 250 °C. Helium was used as carrier gas in the gas chromatographer with 1 iL injection volume. The MS was operated at electron ionization energy of 70 eV. The sample was run for 20 min. Absolute ethanol was used as standard.

The morphology and physical property changes of untreated, alkali pretreated and Trichoderma harzianum strain HZN11 hydrolyzed sweet sorghum bagasse samples were analyzed by SEM (JOEL-JSM 5600, JAPAN). The lyophilized samples were mounted on aluminum stubs, and sputter-coated with a gold layer. The SEM images were taken at different magnifications. SEM equipped with EDX technique was used for elemental analysis of the substrate.

FTIR (Perkin Elmer, FTIR1760) was used to investigate the structural changes in untreated, alkali pretreated and Trichoderma harzianum strain HZN11 hydrolyzed sweet sorghum bagasse samples. Samples were mixed with KBr (potassium bromide) and prepared pellets. The spectra of samples were obtained using 32 scans with the spectra resolution measured as 4 cm- with a scanning range of 500-4000 cm-1.

Results and discussion

Purification of endo ß-1,4-D-glucanase and molecular mass determination

The endo ß-1,4-D-glucanase produced by Trichoderma harzianum strain HZN11 was purified to homogeneity by (NH4)2SO4 precipitation, DEAE-Sepharose and Sephadex G-100 chromatography. The enzyme was purified to 33.12 fold with specific activity of 66.25 U/mg protein as shown in Table 1. The elution profiles of DEAE-Sepharose and Sephadex G-100 chromatography are shown in Fig. S1 (Supplementary Information, SI) which did not show any multiple isoforms of enzyme.

The purified endo ß-1,4-D-glucanase showed a single protein band on SDS-PAGE with molecular weight *55 kDa (Fig. 1) and was found to be a monomeric protein from native gel (data not shown). There are reports of varying molecular mass of endo ß-1,4-D-glucanase from different organisms, 29 kDa from Aspergillus niger AT-3 (Dutt and Kumar 2014) and 62 kDa from P. betulinus (Valaskova and Baldrian 2006).

Characterization of purified endo ß-1,4-D-glucanase

Effect of pH and temperature

The purified endo ß-1,4-D-glucanase was remarkably active in the pH range of 4-6.5 with optimum pH at 5.5 as shown

Fig. 1 SDS-PAGE with lane a: purified endo b-1,4-D-glucanase and lane b: Molecular weight markers

Table 1 Purification summary of endo ß-1,4-D-glucanase from Trichoderma harzianum strain HZN11

Purification steps

Total volume (mL)

protein (mg)

activity (U)

Specific activity (U/mg)

Yield (%)


Crude extract 200

Ammonium sulfate 25 Fractionation (70 %)

DEAE-Sepharose 8

Sephadex G-100 4

1800 325

32.8 3.2

3600 1150

456 212

13.9 66.25

12.7 5.9

6.95 33.12

jjjilliir dlloJI iiii» Л\ Cnrinapr

KAcsTäLLöUiq inkij ^ springer


¡3 0.03

-0.6 -0.4 -0.2

-1/Km -0.01

0.2 0.4 0.6 0.8 1/[S] (mg/ml)

00mM 05mM A10mM 0.07-,

-0.2 0 -0.01J

0.2 0.4 0.6 0.8 1/[CMC] mg/ml

Fig. 2 Determination of kinetic parameters Km and Vmax by Line-weaver-Burk plot (a) and inhibition kinetics by cellobiose on purified endo b-1,4-D-glucanase (b)

in Fig. S2A (SI). Fungal cellulases have found to be active in acidic pH. The charge distribution on substrate and enzyme is greatly affected by variation in pH intern affecting the mechanism of substrate binding and catalysis (Shah and Madamwar 2005). Enzyme stability at its optimum pH is a required for efficient catalysis. 81, 85 and 77 % of activity was retained at pH 5, 5.5 and 6, respectively, after 3 h (Fig. S2B, SI), thereby anticipating good pH stability. Similarly, effect of temperature was evaluated in the range between 20-85 °C. Endo p-1,4-D-glucanase from Trichoderma harzianum strain HZN11 was found to be highly stable between 50-70 °C with optimum activity at 60 °C indicated in Fig. S2C (SI). The relative activity was recorded to be 80, 77, 76 and 66 % at 50, 55, 60 and 65 °C, respectively, after 3 h (Fig. S2D, SI). The results reveal an acidic pH stable and thermostable endo p-1,4-D-glucanase from Trichoderma harzianum strain HZN11 which could be employed for enzymatic hydrolysis of lignocellulosic biomass. Thermal stability of an enzyme is an attractive property for significant industrial applications (Asgher and Iqbal 2011). Many investigators reported optimum reaction temperature of 50-75 °C. Our results were similar to other endoglucanases from Trichoderma viride HG 623 with temperature and pH of 55 °C with pH 5

and stable for 1 h from 35 to 55 °C between 3.0-7.5 pH (Huang et al. 2013). Cellulase from Fusarium oxysporum JRE1 strain exhibited maximum activity at pH 5.6 retaining 75 % activity between pH 4.0-7.0 and 70 % activity around 25-37 °C (Dar et al. 2013).

Effect of metal ions, additives, detergents, surfactants, oxidizing agents and organic solvents

The effect of various metal ions on endo p-1,4-D-glucanase activity at different concentrations (1-10 mM) is shown in Table S1 (SI). The metal ions such as Ca2+, Mg2+, Mn2+, Fe2? and Co2? activated the enzyme at 1 mM concentration whereas Hg2?, Pb2?, Zn2? and Cd2? inhibited the enzyme. Similar results have been reported for endo p-1,4-D-glucanase from Fusarium oxysporum JRE1 (Dar et al. 2013) and Penicillium pinophilum MS20 (Pol et al. 2012).

Additives like DTT, p-mercaptoethanol, EDTA and urea activated the enzyme and PMSF, N-bromosuccinimide, DMSO, iodoacetamide, p-CMB and 1, 10-phenathroline inhibited the enzyme as shown in Table S1 (SI). Endo p-1,4-D-glucanase inhibition in the presence of iodoac-etamide and p-CMB indicate the binding to the -SH groups. Activation by DTT and p-mercaptoethanol indicate the presence of thiol groups at the active sites and these chemicals cause the reduction of disulphide bonds and reactivate the enzyme (Singh et al. 1990). Inhibition by N-bromosuccinimide suggests the presence of tryptophan residues in the active sites (Kaur et al. 2015). Similar results have been reported for cellulases from Bacillus subtilis YJ1 (Yin et al. 2010) and Bacillus vallismortis RG-07 (Gaur and Tiwari 2015).

Endo p-1,4-D-glucanase showed good stability in the presence of detergents retaining 90, 85, 68, 71 and 76 % activity with 1 % of SDS, sodium tetraborate, tide, ariel and surf excel, respectively. Surfactants like tween-20, tween-40, tween-80 and triton X-100 retained greater than 80 % of the activity at 1 %. Endo p-1,4-D-glucanase retained 64, 73 and 40 % of activity with 1 % oxidizing agents like sodium perborate, sodium hypochlorite and hydrogen peroxide, respectively (Table S2, SI). Detergents may cause alterations in the structural and conformational characteristics of enzymes (Bajaj et al. 2009). The detergent stability of cellulase is an important attribute to be an effective additive in commercial detergents. A cold-active endoglucanase from Aspergillus terreus strain AKM-F3 was found to be resistant to triton X-100 (Maharana and Ray 2015). Appreciable stability of cellulase from Bacillus vallismortis RG-07 for non-ionic surfactants and detergent at 1 % and oxidizing agents at 0.1 % has been reported (Gaur and Tiwari 2015).

The enzyme showed more than 75 % of relative activity in most of the organic solvents like glycerol, ethanol,

¿1 Snrinopr

KAcsTiuiUi, ^wj ^ springer

methanol, acetone, propanol, petroleum ether, isopropanol, benzene, cyclohexane, hexane, butanol and toluene even at 30 % concentration (Table S3, SI). Solvent tolerant enzymes are needed for industrial applications. The enzyme stability in organic solvents may be attributed to its ability to form numerous hydrogen bonds with water, leading to structural flexibility and conformational mobility (Klibanov 2001). In agreement to our results, cold-active endoglucanase from Aspergillus terreus strain AKM-F3 and cellulase from Bacillus vallismortis RG-07 was also found to be stable in most organic solvents (Gaur and Tiwari 2015; Maharana and Ray 2015).

Substrate specificity and enzyme kinetics

Purified endo ß-1,4-D-glucanase exhibited highest substrate specificity with CMC (Table S4, SI). It also showed slight activity with filter paper and microcrystalline cellulose. In agreement with our findings, endoglucanse from P. betulinus, Bacillus subtilis YJ1 and Daldinia eschscholzii also showed highest substrate specificity for CMC (Karn-chanatat et al. 2008; Valaskova and Baldrian 2006; Yin et al. 2010). Endoglucanase reported from Aspergillus nidulans showed activity with pNP-ß-D-lactopyranoside and pNP-cellobioside substrates, and hence belonged to GH7 family (Kaur et al. 2015).

Furthermore, endo ß-1,4-D-glucanase activity increased with increasing substrate concentration up to 22.5 mg/mL, and then saturation was observed due to the saturation of enzyme active sites. Kinetics of enzyme revealed the Km and Vmax of 2.5 mg/mL and 83.75 U/mg, respectively, for CMC shown in Fig. 2a. Lower Km value indicates strong affinity for the substrate CMC. A Km and Vmax of 19.39 g/L and 0.0948 mM/L/min, respectively, was reported by T. harzianum IOC-3844 (de Castro et al. 2010). Endoglu-canase from Penicillium pinophilum MS20 was active towards CMC with Km of 4.8 mg/mL and Vmax of 78.5 U/mg (Pol et al. 2012). Inhibition studies showed cel-lobiose to be competitive inhibitor of endo ß-1,4-D-glu-canase in the presence of CMC substrate with a Ki of 0.066 M shown in Fig. 2b. Similar observations were also reported for endoglucanase from Daldinia eschscholzii (Karnchanatat et al. 2008). About 87 % of activity was retained by purified endo ß-1,4-D-glucanase when compared to crude enzyme with 30 % activity after 60 days of storage stability (Fig. S3, SI).

Enzymatic hydrolysis and ethanol fermentation

In the process of production of cellulosic bioethanol, pre-treatment and enzymatic hydrolysis is the crucial steps for saccharification and the reducing sugars could be fermented to ethanol. Untreated and alkali pretreated sweet

sorghum bagasse and sugarcane bagasse were used to test the ability of the purified endo b-1,4-D-glucanase with other crude hydrolytic enzyme cocktail and commercial cellulase for the production of fermentable sugar by enzymatic hydrolysis. Alkali pretreated sweet sorghum and sugarcane bagasse released higher amounts of reducing sugars as compared to untreated. Maximum reducing sugars of 3.7 and 5.2 g/g were produced from sweet sorghum and sugarcane bagasse, respectively, at 48 h when treated with purified endo b-1,4-D-glucanase mixture of cocktail, in comparison to commercial cellulase which produced 2.4 and 4.3 g/g of reducing sugars with sweet sorghum and sugarcane bagasse, respectively, at 48 h represented in Fig. 3a. Hence, the efficient bioconversion of lignocellu-losic biomass necessarily requires the synergetic action of cellulolytic enzymes, depolymerizing and debranching hemicellulolytic enzymes. Enzymatic hydrolysis of the alkali pretreated sweet sorghum and sugarcane bagasse into glucose was optimized. Optimization of hydrolysis time and temperature revealed high amounts of sugars 5.2 g/g at 36 h and 6.8 g/g at 48 h from alkali pretreated sweet sorghum and sugarcane bagasse, respectively, at 50 °C indicated in Fig. 3b. Therefore, these process parameters play an essential role in hydrolysis of lignocelluloses to get efficient yield of reducing sugars. Moreover, short processing times are a key parameter to an economically viable industrial process. Formulation of cellulase enzymes is challenging for hydrolysis process but will not only lower the enzyme loadings but also reduce the capital cost in a cellulosic bioethanol production. In agreement to our results, crude enzyme cocktail from T. harzianum KUC1716 and S. commune KUC9397 could replace the commercial enzymes with approx 80 % hydrolysis yield (Lee et al. 2015). A similar study reported by Patel et al. (2015) on hydrolysis of pretreated maize stover suggests that enzyme cocktail with commercial cellulase results in better sugar release. Vimala et al. (2011) studied the effect of different pretreatment strategies for enzymatic hydrolysis of sorghum straw and found that alkali delignified treatment released higher sugars. To minimize the process cost is of great importance for an economical cellulose-based ethanol production. Even if the new enzyme mixes are said to have improved efficiency, the enzyme cost is still contributing to a big part of the total production cost. The present study indicated that the purified endo b-1,4-D-glucanase with cocktail obtained from Trichoderma harzianum strain HZN11 enhanced the efficiency of biomass hydrolysis.

In SHF, ethanol produced was qualitatively detected by GC-MS. Spectral analysis for ethanol produced from sweet sorghum bagasse after 24 h by Saccharomyces cerevisiae NCIM 3594 showed two peaks in Fig. S4A (SI). Peak 1 showing a retention time of 1.585 with a molecular mass of

jjjilliir dllall ¿in« c •

KAcsToLLaUiq rnqiiU ^ apringer

■ Alkali pretreated with enzyme cocktail

■ Crude with enzyme cocktail

■ Alkali pretreated with Commercial enzyme Crude with Commercial enzyme

я 3 -

BJJ 2 -

■5 2 ä

20 40 60

Time (h)

Sweet sorghum with enzyme cocktail at 50°C Sugarcane with enzyme cocktail at 50°C Sweet sorghum with enzyme cocktail at 60°C Sugarcane with enzyme cocktail at 60°C

Time (h)

58 indicating the presence of acetone according to the data published previously (Tiscione et al. 2011) whereas peak 2 showing a retention time of 1.643 with a mass of 46 indicating the presence of ethanol by comparison with standard ethanol peak in Fig. S4B (SI). Tiscione et al. (2011) also obtained a similar mass spectrum for ethanol by GC-MS indicating this to be an excellent method for ethanol detection by GC-FID and simultaneous confirmation by MS. In SHF, the fermentation of sweet sorghum hydrolyzate by Saccharomyces cerevisiae NCIM 3594 produced ethanol (4.3 g/L) at 16 h indicating the utilization of reducing sugars. Reducing sugar concentration in hydrolyzate decrease from 5.2 to 0.38 g/L within 24 h of fermentation with a cell biomass of 4.4 g/L indicated in Fig. 3c. Mukhopadhyay and Chatterjee (2010) reported 4.5 g/L ethanol with pretreated water hyacinth after 72 h of enzymatic hydrolysis in SHF. Sorghum juice and sorghum press cake fermentation produced 9.2 and 5.6 % (w/v) ethanol (Mamma et al. 1995). Interesting one-pot bioe-thanol production process with A. cellulolyticus C-1 and S. Cerevisiae co-cultures using Solka-Floc were reported (Park et al. 2012). End product inhibition by glucose is a serious problem in SHF. The main advantage is the possibly to separately optimize the process steps. Hence, we report the successful production of bioethanol by SHF of sweet sorghum bagasse with good ethanol concentration.

I О m я я .¡3

"мi^ и я

- Initial glucose conc g/g

- Cell Biomass g/L

-Ethanol g/L

- 0.5 0

Fig. 3 Enzymatic hydrolysis of untreated and pretreated sweet sorghum bagasse with purified endo P-1,4-D-glucanase mixed cocktail and commercial enzyme at 40 °C (a), optimization of temperature and time for enzymatic hydrolysis of alkali pretreated sweet sorghum and sugarcane bagasse with purified endo P-1,4-D-glucanase mixed cocktail (b), and production of ethanol from sweet sorghum bagasse hydrolyzate fermented by Saccharomyces cerevisiae NCIM 3594 (c). Data values represent average of triplicates and error bars represent standard deviation

SEM and elemental analysis

Scanning electron microscopy studies depict the plant tissue's morphological and structural changes occurring during pretreatment and hydrolysis. Untreated sweet sorghum bagasse showed a unique structure of the fibers. No pores occurred in large amount as the entire structure was closed indicating to be recalcitrant observed in Fig. 4a. It also reveals intact plant cell wall with vascular bundles and a highly fibrillar structure.SEM image of alkali pretreated sweet sorghum bagasse depicts the alteration in fibrillar structure analyzed in Fig. 4b. Pretreatment usually dislocates the bonding among cellulose, hemicelluloses and lignin by dissolving hemicelluloses, but major microfibrous cellulose structures remain unaltered and some lignin-car-bohydrate complexes may be packed on the surface of the cellulose fibers. During pretreatment, hydrocarbons are removed and initiates development of cracks on the lig-nocellulosic fiber, further increasing the porosity which exposure the cellulosic portion for efficient bioconversion. SEM image of sweet sorghum bagasse hydrolyzed by Trichoderma harzianum strain HZN11 showed intact cells on the substrate particles clearly observed in Fig. 4c.

1 Snrinapr

KAcsTöajüUig ^laU ^ springer

Fig. 4 SEM analysis of untreated sweet sorghum bagasse (a), alkali pretreated sweet sorghum bagasse (b) and pretreated sweet sorghum bagasse hydrolyzed by Trichoderma harzianum strain HZN11(c)

Hydrolysis increases the porosity and evidence the utilization of cellulosic material for sugar production. SEM has been also employed to study the surface morphological changes of chars obtained from gasification process of switchgrass, sorghum and red cedar char (Qian et al. 2013). Hard raw sugarcane bagasse and holes after treatment was


kacstolloUIq rnqjiU ^ springer

evidenced indicating saccharification process by SEM analysis (Irfan et al. 2011). A smooth surfaced compact structure and intact morphology of untreated and significant increase in porosity of pretreated sorghum stem was visualized by SEM (Nikzad et al. 2014).

The elemental analysis of biomass was carried out by SEM equipped with EDX technique. Usually raw biomass has high amounts of potassium (K) and chorine (Cl) as they remain in ionic form and are not metabolized by the plant (Lehmann et al. 2011). The SEM/EDX analyses are shown in Fig. S5A (SI) for untreated, Fig. S5B (SI) for alkali pretreated and Fig. S5C (SI) for Trichoderma harzianum strain HZN11hydrolyzed sweet sorghum bagasse. The untreated bagasse was composed of carbon (65.47 %) which was gradually reduced to 60.15 % in pretreatment and further reduced to 58.32 % after hydrolysis indicating the utilization of carbon by the organism for enzyme production (Table S5, SI). The nitrogen content in pretreated bagasse may be exposed due to delignification. The presence of sodium may be attributed to alkali pretreatment process. Gradual decrease in the content of minerals and metals in the hydrolyzed bagasse may be due to its utilization by the organism. The increase in nitrogen content as compared to the raw biomass may be predicted due to the stability of nitrogen containing compounds such as heterocyclic aromatic compounds (Cantrell et al. 2012). Fuel characteristics of biomass were studied by this technique. Hence, we report an interesting study on elemental analysis of sweet sorghum bagasse, thereby understanding the insights of nutritional changes and its utilization by Trichoderma harzianum strain HZN11during biomass hydrolysis.

FTIR analysis

The structural changes in untreated, alkali pretreated and Trichoderma harzianum strain HZN11 hydrolyzed sweet sorghum bagasse were analyzed by FTIR. The spectrum of untreated, alkali treated and Trichoderma harzianum strain HZN11 hydrolyzed sweet sorghum bagasse are shown in the Fig. S6 (SI). Stretching of hydroxyl group increased after alkali pretreatment and hydrolysis of bagasse. The degradation of fibrillar structure of cellulose and lignin is observed after alkaline treatment. A peak of amines N-H stretch is established around 3419 cm-1 in untreated and alkali pre-treated bagasse and disappeared in hydrolyzed bagasse. Peak around 2915 cm- in alkali treated bagasse arises from C-H stretching, further suggesting that the hydrolysis process may destroy aliphatic structures in the biomass. Urethane amides stretch was detected around 1734 cm- range in untreated bagasse. Strong aromatic ring (aromatic lignin) stretch was observed in 1600-1500 cm- range with aromatic C=C bending in untreated bagasse. Lower band intensity at this

wavelength in pretreated and hydrolyzed bagasse signifies delignification effect. In treated and hydrolyzed bagasse peaks around 1315 cm- are correlated to absorption by C-H and C-O stretching of acetyl group in hemicelluloses. C-O stretching of aryl ethers, and phenolics of lignin-derived compounds and C-O stretching of pyranone rings and gua-iacyl monomers around 1250 cm-1 and presence of aliphatic amines C-N stretch around 1244 cm-1 in untreated bagasse were observed. Glycosidic linkage was predicted in untreated and pretreated bagasse around 1200-1150 cm-1. A C-O or C-O-C stretching around 1161 cm- was observed predicting cellulose and hemicellulose structure and peaks around 1100-1050 cm- were attributed to p(1-3) polysaccharide in pretreated and hydrolyzed bagasse. A peak found around 898 cm- was established for cellulose which increases after pretreatment. FTIR spectra illustrated the delignification activities during pretreatment and further degradation of bagasse by enzymatic hydrolysis by Trichoderma harzianum strain HZN11. Previous reports on FTIR analysis of ligno-cellulosic biomass also conclude similar observations (Adapa et al. 2011; Qian et al. 2013). Similar structural changes have been studied in undecayed and decayed lime wood with T. viride (Popescu et al. 2010). The effective utilization of sweet sorghum bagasse for enzyme production is clearly evidenced in our study.


In the present study, the Trichoderma harzianum strain HZN11 produced a highly active endo p-1,4-D-glucanase using sweet sorghum bagasse. The purified endo p-1,4-D-glucanase was found to possess the attributes of industrial enzymes like solvent-thermostable-acidophilic nature. The major bottleneck in the biomass to bioethanol production is the high cost of the cellulolytic enzymes. In the present study, attempts to produce bioethanol from sweet sorghum hydrolyzate by SHF were successful. Enzymatic hydrolysis with purified endo p-1,4-D-glucanase mixed with cocktail was efficient in comparison to commercial enzyme. FTIR and SEM/EDX analysis provided the molecular insights of alkali pretreated and hydrolyzed bagasse indicating hydrolysis of plant biomass. The purified enzyme finds huge potential in biofuel and various other industries.

Acknowledgments First author thank KLE Technological University, B.V. Bhoomaraddi College of Engineering and Technology, Hubballi and Research and Development Promotion Cell (RDPC) for providing research facility.

Compliances with ethical standards

Conflict of interest The author(s) declare(s) that there is no conflict of interest regarding the publication of this article.

Open Access This article is distributed under the terms of the Creative Commons Attribution 4.0 International License (http://, which permits unrestricted use, distribution, and reproduction in any medium, provided you give appropriate credit to the original author(s) and the source, provide a link to the Creative Commons license, and indicate if changes were made.


Adapa PK, Tabil LG, Schoenau GJ, Canam T, Dumonceaux T (2011) Quantitative analysis of lignocellulosic components of non-treated and steam exploded barley, canola, oat and wheat straw using Fourier transform infrared spectroscopy. J Agric Sci Technol B 1:177-188 Asgher M, Iqbal HMN (2011) Characterization of a novel manganese peroxidase purified from solid state culture of Trametes versicolor IBL-04. Bioresources 6:4302-4315 Bajaj BK, Pangotra H, Wani MA, Sharma P, Sharma A (2009) Partial purification and characterization of a highly thermostable and pH stable endoglucanase from a newly isolated Bacillus strain M-9. Indian J Chem Technol 16:382-387 Bakare MK, Adewale IO, Ajayi AO, Okoh AI, Shonukan OO (2005) Regulatory mutations affecting the synthesis of cellulase in Pseudomonas fluorescens. Afr J Biotechnol 4:838-843 Bentsen NS, Felby C (2012) Biomass for energy in the European Union-a review of bioenergy resource assessments. Biotechnol Biofuels 5(1):25

Bhat MK (2000) Cellulases and related enzymes in biotechnology.

Biotechnol Adv 18(5):355-383 Bhat MK, Bhat S (1997) Cellulose degrading enzymes and their

potential industrial applications. Biotechnol Adv 15:583-620 Cantrell KB, Hunt PG, Uchimiya M, Novak JM, Ro KS (2012) Impact of pyrolysis temperature and manure source on physic-ochemical characteristics of biochar. Bioresour Technol 107:419-428

Dar RA, Saba I, Shahnawaz M, Sangale MK, Ade AB, Rather SA, Qazi PH (2013) Isolation, purification and characterization of carboxymethyl cellulase (CMCase) from endophytic Fusarium oxysporum producing podophyllotoxin. Adv Enzyme Res 1:91-96

de Castro AM, Ferreira MC, da Cruz JC, Pedro KC, Carvalho DF, Leite SG, Pereira N (2010) High-yield endoglucanase production by Trichoderma harzianum IOC-3844 cultivated in pretreated sugarcane mill byproduct. Enzyme Res 2010:854526 Dhillon GS, Oberoi HS, Kaur S, Bansal S, Brar SK (2011) Value-addition of agricultural wastes for augmented cellulase and xylanase production through solid-state tray fermentation employing mixed-culture of fungi. Ind Crop Prod 34:1160-1167 Dutt D, Kumar A (2014) Optimization of cellulase production under solidstate fermentation by Aspergillus flavus (AT-2) and Aspergillus niger (AT-3) and its impact on stickies and ink particle size of sorted office paper. Cell Chem Technol 48:285-298 Gaur R, Tiwari S (2015) Isolation, production, purification and characterization of an organic-solvent-thermostable alkalophilic cellulase from Bacillus vallismortis RG-07. BMC Biotechnol 15:19

Ghose VK (1987) Measurement of cellulase activities. Pure Appl

Chem 59:257-268 Huang X, Ge J, Fan J, Chen X, Xu X, Li J, Zhang Y, Zhou D (2013) Characterization and optimization of xylanase and endoglu-canase production by Trichoderma viride HG 623 using response surface methodology (RSM). Afr J Microbiol Res 7:4521-4532

¿1 Snrinopr

KAcsTöojüUig ^laU ^ springer

Irfan M, Syed Q, Abbas S, Sher MG, Baig S, Nadeem M (2011) FTIR and SEM analysis of thermo-chemical fractionated sugarcane bagasse. Turk J Biochem 36:322-328 Karmakar M, Ray RR (2011) Current trends in research and

application of microbial cellulases. Res J Microbiol 6:41-53 Karnchanatat A, Petsom A, Sangvanich P, Piapukiew J, Whalley AJS, Reynolds CD, Gadd GM, Sihanonth P (2008) A novel thermostable endoglucanase from the wood-decaying fungus Daldinia eschscholzii (Ehrenb.:Fr.) Rehm. Enzyme Microb Technol 42:404-413 Kaur B, Oberoi HS, Chadha BS (2015) Comparative analysis of two catalytically distinct endoglucanases from Aspergillus nidulans. J Appl Biol Biotechnol 3:22-29 Klibanov AM (2001) Improving enzymes by using them in organic

solvents. Nature 409:241-246 Kuhad RC, Gupta R, Singh A (2011) Microbial cellulases and their

industrial applications. Enzyme Res 2011:280696 Laemmli UK (1970) Cleavage of structural proteins during the assembly of the head of bacteriophage T4. Nature 227(5259):680-685 Lee H, Lee YM, Heo YM, Lee H, Hing JH, Jang S, Min M, Lee J, Kim JS, Kim GH, Kim JJ (2015) Optimization of endoglucanase production by Trichoderma harzianum KUC1716 and enzymatic hydrolysis of lignocellulosic biomass. Bioresources 10:7466-7476

Lehmann J, Rillig MC, Thies J, Masiello CA, Hockaday WC, Crowley D (2011) Biochar effects on soil biota—a review. Soil Biol Biochem 43:1812-1836 Lowry OH, Rosebrough NJ, Farr AL, Randall RJ (1951) Protein measurement with the Folin phenol reagent. J Biol Chem 193(1):265-275

Lynd LR, Weimer PJ, van Zyl WH, Pretorius IS (2002) Microbial cellulose utilization: fundamentals and biotechnology. Microbiol Mol Biol Rev 66(3):506-577 Maharana AK, Ray P (2015) Optimization and characterization of cold-active endoglucanase produced by Aspergillus terreus strain AKM-F3 grown on sugarcane bagasse. Turk J Biol 39:175-185

Mamma D, Christakopolos P, Kollas D, Kekos D, Macris BJ, Koukios E (1995) An alternative approach to the bioconversion of sweet sorghum carbohydrates to ethanol. Biomass Bioenerg 8:99-103 Miller GL (1959) Use of dinitrosalicyclic acid reagent for determination of reducing sugar. Biotechnol Bioeng Symp 5:193-219 Mukhopadhyay SC, Chatterjee NC (2010) Bioconversion of water

hyacinth hydrolysate into ethanol. Bioresources 5:1301-1310 Nikzad M, Movagharnejad K, Talebnia F, Najafpour G, Ghorban AH, Farah A (2014) Study on alkali pretreatment conditions of sorghum stem for maximum sugar recovery using statistical appraoch. Chem Ind Chem Eng Q 20:261-271 Pandey A, Selvakumar P, Soccol CR, Nigam P (1999) Solid state fermentation for the production of industrial enzymes. Curr Sci 77:149-162

Park EY, Naruse K, Kato T (2012) One-pot bioethanol production from cellulose by co-culture of Acremonium cellulolyticus and Saccharomyces cerevisiae. Biotechnol Biofuels 5(1):64

Patel H, Chapla D, Divecha J, Shah A (2015) Improved yield of a-L-arabinofuranosidase by newly isolated Aspergillus niger ADH-11 and synergistic effect of crude enzyme on saccharification of maize stover. Bioresour Bioprocess 2:11 Pol D, Laxman RS, Rao M (2012) Purification and biochemical characterization of endoglucanase from Penicillium pinophilum MS 20. Indian J Biochem Biophys 49(3):189-194 Popescu CM, Popescu MC, Vasile C (2010) Structural changes in

biodegraded lime wood. Carbohydr Polym 79:362-372 Qian K, Kumar A, Patil K, Bellmer D, Wang D, Yuan W, Huhnke RL (2013) Effects of biomass feedstocks and gasification conditions on the physiochemical properties of char. Energies 6:3972-3986 Ren N, Wang A, Cao G, Xu J, Gao L (2009) Bioconversion of lignocellulosic biomass to hydrogen: potential and challenges. Biotechnol Adv 27(6):1051-1060 Saha BC (2004) Production, purification and properties of endoglu-canase from a newly isolated strain of Mucor circinelloides. Process Biochem 39:1871-1876 Shah AR, Madamwar D (2005) Xylanase production by a newly isolated Aspergillus foetidus strain and its characterization. Process Biochem 40:1763-1771 Sim SF, Mohamed M, Mohd Irwan LuNAL, Sarman NSP, Samsudin SNS (2012) Computer-assisted analysis of fourier transform infrared (FTIR) spectra for characterization of various treated and untreated agriculture biomass. Bioresources 7:5367-5380 Singh A, Agrawal AK, Abidi AB, Darmwal NS (1990) Properties of cellobiase from Aspergillus niger. Appl Microbiol Biotechnol 34:356-358

Tiscione NB, Alford I, Yeatman DT, Shan X (2011) Ethanol analysis by headspace gas chromatography with simultaneous flame-ionization and mass spectrometry detection. J Anal Toxicol 35(7):501-511

Valaskova V, Baldrian P (2006) Degradation of cellulose and hemicelluloses by the brown rot fungus Piptoporus betulinuspro-duction of extracellular enzymes and characterization of the major cellulases. Microbiology 152:3613-3622 Vimala RA, Sateesh L, Sridevi J, Venkateswarlu B, Venkateswar Rao L (2011) Enzymatic hydrolysis of sorghum straw using native cellulase produced by T. reesei NCIM 992 under solid state fermentation using rice straw. 3 Biotech 1(4):207-215 Yin LJ, Lin HH, Xiao ZR (2010) Purification and characterization of a cellulase from Bacillus subtilis YJ1. J Mar Sci Technol 18:466-471

Zhang J, Siika-Aho M, Puranen T, Tang M, Tenkanen M, Viikari L (2011) Thermostable recombinant xylanases from Nonomuraea flexuosa and Thermoascus aurantiacus show distinct properties in the hydrolysis of xylans and pretreated wheat straw. Biotech-nol Biofuels 4:12 Zhu M, Li P, Gong X, Wang J (2012) A comparison of the production of ethanol between simultaneous saccharification and fermentation and separate hydrolysis and fermentation using unpretreated cassava pulp and enzyme cocktail. Biosci Biotechnol Biochem 76:671-678

jjjilliir dlloJI iiii» Л\ Cnrinapr KACSTÖLLÖUlq inJslJ ^ springer