Scholarly article on topic 'Fermentative Succinate Production: An Emerging Technology to Replace the Traditional Petrochemical Processes'

Fermentative Succinate Production: An Emerging Technology to Replace the Traditional Petrochemical Processes Academic research paper on "Biological sciences"

CC BY
0
0
Share paper
Academic journal
BioMed Research International
OECD Field of science
Keywords
{""}

Academic research paper on topic "Fermentative Succinate Production: An Emerging Technology to Replace the Traditional Petrochemical Processes"

Hindawi Publishing Corporation BioMed Research International

Volume 2013, Article ID 723412,12 pages ^ W M

http://dx.doi.org/10.1155/2013/723412

Hindawi

Review Article

Fermentative Succinate Production: An Emerging Technology to Replace the Traditional Petrochemical Processes

Yujin Cao, Rubing Zhang, Chao Sun, Tao Cheng, Yuhua Liu, and Mo Xian

CAS Key Laboratory of Bio-Based Materials, Qingdao Institute ofBioenergy and Bioprocess Technology, Chinese Academy of Sciences, Qingdao 266101, China

Correspondence should be addressed to Mo Xian; xianmoqibebt@hotmail.com Received 3 August 2013; Revised 13 October 2013; Accepted 1 November 2013 Academic Editor: Phillip E. Klebba

Copyright © 2013 Yujin Cao et al. This is an open access article distributed underthe Creative Commons Attribution License, which permits unrestricted use, distribution, and reproduction in any medium, provided the original work is properly cited.

Succinate is a valuable platform chemical for multiple applications. Confronted with the exhaustion of fossil energy resources, fermentative succinate production from renewable biomass to replace the traditional petrochemical process is receiving an increasing amount of attention. During the past few years, the succinate-producing process using microbial fermentation has been made commercially available by the joint efforts of researchers in different fields. In this review, recent attempts and experiences devoted to reduce the production cost of biobased succinate are summarized, including strain improvement, fermentation engineering, and downstream processing. The key limitations and challenges faced in current microbial production systems are also proposed.

1. Introduction

Succinate, also known as 1,4-butanedioic acid or amber acid, is a four-carbon dicarboxylic acid for multiple applications. Succinate and its desirable properties have been known for a long time. In the agricultural field, succinate is a known growth regulator [1] which can be used for seed treatment and plant rooting. In the food industry, succinate is used as a flavoring enhancer for beverages, a bread softening agent, and a catalyst for food seasoning preparation [2]. It is generally considered as safe and has been approved by the US Food and Drug Administration. In the pharmaceutical industry, succinate acts as an anticarcinogenic agent and as an insulinotropic agent [3]. In the chemical industry, succinate is a precursor for the production of many high-value chemicals including 1,4-butanediol, tetrahydrofuran, y-butyrolactone, and 2-pyrrolidinone [4]. Finally, succinate is a precursor to many specialized polyesters, for example, polybutylene succinate (PBS) [5], which might be its most promising application area.

Due to its versatile applications, succinate is rising to a bulk chemical in recent years. The global production is estimated between 30,000 and 50,000 tons per year [6]. According to a survey report from MarketsandMarkets,

the market of succinate is expected to grow at a rate of 18.7% from 2011 to 2016 [7]. The global market for succinate in terms of revenue was estimated to be worth $182.8 million in 2010 and is expected to reach $496.0 million by 2016. As shown in Figure 1, Europe and North America were the largest two markets in 2010, accounting for 35.0% and 31.0% of the global succinate demand, respectively. Asia-Pacific was the third succinate consuming regions and is expected to be the fastest growing market in the near future owing to the strong demand from key countries such as China and India. The increasing demand of succinate is promoting us to develop cost effective synthesis routes to support its evergrowing markets.

2. The Limitation of Traditional Petrochemical Succinate-Producing Processes

Succinate is traditionally manufactured through chemical routes using paraffin, maleic anhydride, acetylene, or acrylic acid as the starting materials. Paraffin oxidation is the initial method to prepare succinate [8]. Under the catalysis of Mn or Ca, paraffin is deeply oxidized to a mixture of dicarboxylic acid. After steam distillation, succinate in the aqueous phase

can be crystallized. This process is well established, but the yield and purity of succinate are relatively low. Another conventional approach widely used to produce succinate is the hydrogenation of maleic anhydride. This process requires several types of noble metal-based catalysts, such as Pd and Ru [9]. In addition, the reaction is carried out under high temperature and high pressure conditions [10], which is not environmental friendly. Electrolytic reduction of maleic anhydride in acidic medium also leads to the production of succinate. The reaction could be conducted under mild conditions and the conversion rate is even higher [11]. However, the consumption of large quantities of electricity power increases the production cost.

Although other chemical synthesis routes such as the catalytic addition of acetylene and acrylic acid using much cheaper feedstocks have been proposed [12], their industrial application is still far from occurring. Along with the decrease of global fossil fuel resources and the rise of crude oil price, these traditionally succinate-producing methods from petrochemicals are becoming costly and causing serious pollution problems, requiring us to find new pathways for succinate manufacture.

3. Metabolic Pathways for Succinate Production by Microbial Fermentation

In the biological systems, succinate is an essential intermediate for cellular metabolism. In addition, it can also be one of the end-products of anaerobic fermentation. Therefore, it is possible to produce succinate using biological processes to substitute the petrochemicals processes. Biological processes are particularly attractive since microorganisms usually utilize renewable feedstocks and produce much fewer toxic by-products. In a report from the US Department of Energy, succinate is listed as the first among the top 12 value-added chemicals manufactured from biomass [13]. Recently, biological routes for succinate production developed by two

companies, BioAmber and Reverdia, are commercially available. These processes are based on proprietary Escherichia coli and yeast strains.

Figure 2 provides an overview of the biosynthetic pathway of succinate from glucose under both anaerobic and aerobic conditions. Under both conditions, glucose is degraded into phosphoenolpyruvate (PEP) and finally to pyruvate by gly-colysis. Through anaerobic fermentation, PEP is the substrate for a carboxylase-catalyzed anaplerotic reaction and can be converted to oxaloacetate by PEP carboxylase (ppc) or PEP carboxykinase (pck). Pyruvate, the end-product of glycolysis, can also be incorporated with CO2 by pyruvate carboxylase (pyc) or malic enzyme (mae), forming oxaloacetate or malate. Both oxaloacetate and malate may be further converted to fumarate by malate dehydrogenase (mdh) and fumarase (fum). Fumarate can be finally reduced to succinate by fumarate reductase (frd) [14].

Under aerobic conditions, succinate is an intermediate of both tricarboxylic acid (TCA) cycle and glyoxylate shunt, but no wild-type microorganism could accumulate it in large quantities. Recently, the oxidative pathway for succinate production has been artificially constructed in E. coli [15], Sac-charomyces cerevisiae [16], and Corynebacterium glutamicum [17] by deleting the critical gene, succinate dehydrogenase (sdh), in the TCA cycle. As two carbons are lost as CO2 in the TCA cycle, the glyoxylate shunt is employed to bypass the steps in the TCA cycle to improve the atom economy. As shown in Figure 2(b), the TCA cycle and the glyoxylate shunt separate at theisocitratepoint. Inorder to blockthe metabolic flux through the TCA cycle, two key regulatory points, sdh and isocitrate dehydrogenase (icd), must be disrupted. Thus, isocitrate enters the glyoxylate shunt and undergoes cleavage into succinate and glyoxylate, which is catalyzed by isocitrate lyase (icl) [18]. Then glyoxylate condenses with acetyl-CoA, yielding malate. Finally, malate enters the residual TCA cycle to regenerate isocitrate. For both anaerobic and aerobic metabolism, branch pathways leading to the formation of formate, acetate, ethanol, and lactate also exist to compete with the succinate-producing pathway.

4. Microbial Succinate Producers

Since the succinate metabolic pathway has been resolved in different biological systems, it is possible to produce this valuable chemical through microbial fermentation. Up to now, a number of fermentative succinate-producing bacteria have been isolated and characterized to some extent. These microorganisms can be generally classified into two categories: natural producers and engineered producers. Several representative species that have been extensively investigated are listed in Table 1.

4.1. Natural Producers. In nature, many wild-type microorganisms are able to produce succinate at high yields. They are mainly belonging to rumen bacteria including facultative anaerobe (Actinobacillus succinogenes [19] and Mannheimia succiniciproducens [20]) and strict anaerobe (Anaerobiospir-illum succiniciproducens [21]). These natural producers show

ho^- ^o

(ÉPÇ)

(jdh) Pyruvate—X~> Lactate

Oxaloacetate

Malate

-> Formate

-> Acetyl-CoA X > Ethanol

Acetyl phosphate Acetate

Pyruvate —> Acetyl phosphate

Cg) (^ack)

Acetyl-CoA X > Acetyl phosphate X > Acetate

Fumarate &

Succinate

a-Ketoglutarate

(^sc^ Succinyl-CoA \ (b)

Figure 2: Anaerobic (a) and aerobic (b) metabolic pathways for the biosynthesis of succinate. Unidirectional arrows indicate that the reactions are irreversible while two-directional arrows indicate that the reactions are reversible. Enzymes whose genes are deleted are indicated by "X" across arrows. The abbreviations for the enzymes catalyzing these reactions are ack, acetate kinase; acn, aconitase; adh, alcohol/acetaldehyde dehydrogenase; cs, citrate synthase; frd, fumarate reductase; fum, fumarase; icd, isocitrate dehydrogenase; id, isocitrate lyase; kgd, a-ketoglutarate dehydrogenase; Idh, lactate dehydrogenase; mae, malic enzyme; mdh, malate dehydrogenase; ms, malate synthase; pck, PEP carboxykinase; pfl, pyruvate-formate lyase; pox, pyruvate oxidase; ppc, PEP carboxylase; pta, phosphotransacetylase; pyc, pyruvate carboxylase; pyk, pyruvate kinase; scs, succinyl-CoA synthetase; and sdh, succinate dehydrogenase.

Table 1: The typical microorganisms used for fermentative succinate production.

Type Species Oxygen requirement

Bacteria Actinobacillus succinogenes Facultative anaerobe

Bacteria Anaerobiospirillum succiniciproducens Strict anaerobe

Bacteria Mannheimia succiniciproducens Facultative anaerobe

Bacteria Bacteroides fragilis Strict anaerobe

Bacteria Enterococcus faecalis Facultative anaerobe

Natural producers Bacteria Klebsiella pneumoniae Facultative anaerobe

Bacteria Succinivibrio dextrinosolvens Strict anaerobe

Fungi Aspergillus niger Facultative anaerobe

Fungi Paecilomyces varioti Facultative anaerobe

Fungi Penicillium simplicissimum Facultative anaerobe

Bacteria Escherichia coli Facultative anaerobe

Engineered producers Bacteria Corynebacterium glutamicum Aerobe

Yeast Saccharomyces cerevisiae Facultative anaerobe

excellent tolerance to osmotic pressure caused by high level of succinate. However, the cultivation of these natural producers always requires expensive nutrient media, thus increasing the production cost.

Many fungal strains such as Paecilomyces varioti [22], Aspergillus niger [23], andPenicillium simplicissimum [24] are also found to be suitable for succinate production. They could secrete succinate as a metabolic by-product under aerobic and/or anaerobic conditions, but the productivity is much lower when compared with the bacterial strains. Besides, succinate is synthesized in the fungal cell mitochondria and has to cross the mitochondrial and cellular membrane [25]. Therefore, it is more favorable to use bacteria for succinate production instead of fungi.

4.2. Engineered Producers. In addition to the natural producers, many microorganisms can be metabolically engineered to produce succinate as a fermentative end-product. These engineered producers are always model microorganisms since they are easy to be genetically modified. A completely engineered pathway is required to render them capable of producing succinate. E. coli, C. glutamicum, and S. cerevisiae are the representatives of these engineered producers. As a reference organism, E. coli is favored by molecular biologists due to its fast growth rate and ease of manipulation [26, 27]. Numerous studies have been conducted on this bacteria and commercial production of succinate has been reached recently. C. glutamicum is one of the few gram-positive bacteria which have been tested for succinate production. Perhaps the highest titer of succinate was obtained in a cell recycling fed-batch culture of this bacterium [28]. S. cerevisiae has been well characterized to achieve high concentrations of succinate to enhance the quality of wine [29]. It is also a potential industrial producer since this yeast could grow under acidic conditions.

5. Strain Improvement to Increase Succinate Productivity

A highly productive strain is the primary factor to achieve an industrial level succinate production. Early studies for

strain improvement mainly relied on identifying and isolating new microbial strains as well as enhancing the succinate-producing ability of currently available strains. Many assay methods for rapid and high-throughput screening of succinate-producing strains were established [30]. However, strain screening always requires considerable amount of time and resources. Along with the development ofmodern biology technology, the molecular mechanisms for biological succinate production have been largely resolved. It is now possible to rationally modify the microbial strains to improve succinate productivity by metabolic engineering tools. Eliminating the competing pathways, altering metabolic flux to channel the flow of key intermediates, and enhancing cofactors supplies would lead to even higher succinate yields [31]. Many studies have been performed on these topics and encouraging results have been obtained during the past few years. In Table 2, we summarize these advances to improve succinate production using different microorganisms.

5.1. Inactivation of the Branch Pathways. As succinate is not the sole product of microbial fermentation, knockout of the enzymes in competitive pathways is an obvious strategy to boost its production. During mixed-acid fermentation under anaerobic conditions, acetate, ethanol, lactate, formate, pyruvate, and succinate make up the major soluble products [51]. The first approach to eliminate these by-products was inactivating the lactate producing pathway since this pathway was simply catalyzed by a single enzyme, lactate dehydrogenase (ldh) [32]. By deleting the genes encoding the known pathway of acetate formation, phosphotransacetylase (pta), and acetate kinase (ackA), the synthesis of this byproduct could be drastically reduced and succinate formation was enhanced [49]. The branch pathway splitting pyruvate into acetyl-CoA and formate by means of pyruvate formate lyase (pfl) would lead to the formation of acetate, ethanol, and formate. However, knockout of the pfl gene individually could only enhance lactate production while the succinate concentration in the pfl mutant strain was even slightly lower when compared to the control strain [52]. Although the ldh and pfl double mutant strain could lead to an improved

Table 2: Overview of metabolic engineering strategies to improve succinate production using different microorganisms.

Strains Genotypes Culture strategies Succinate production References

Escherichia coli

SBS110MG AadhE, AldhA, expression of Lactococcus lactis pyc Batch 15.6 g/L, 1.3 mol/mol glucose [32]

NZN111 ApflB, AldhA Fed-batch 28.2 g/L, 1.13 mol/mol glucose [33]

AFP111 AldhA, AptsG Batch 0.88 mol/mol glucose [34]

W3110GFA AptsG, ApykF, ApykA Batch 17.35 mM [35]

QZ1111 AptsG, ApoxB, Apta, AsdhA, AiclR Batch 1.45 mmol/(g-h) [36]

HL27659k AsdhAB, AackA-pta, ApoxB, AiclR, AptsG Fed-batch 0.91 mol/mol glucose [37]

KJ073 AldhA, AadhE, AackA, AfocA-pflB, AmgsA, ApoxB Batch 1.2 mol/mol glucose [38]

JCL1208 overexpression of native ppc Batch 10.7 g/L [39]

xz320 AackA, AldhA, AadhE, ApflB, AmgsA, ApoxB, Appc Fed-batch 348 mM [40]

LS1 AldhA, overexpression of native mae Batch 2.34 g/L [41]

NZN111 ApflB, AldhA, overexpression ofnative mdh Fed-batch 15.2 g/L [42]

NZN111 ApflB, AldhA, overexpression of native mae andfum AadhE, AldhA, Apta-ackA, Batch 7 g/L [43]

SBS990MG expression ofLactococcus lactis pyc Batch 1.7 mol/mol glucose [44]

NZN111 ApflB, AldhA, overexpression ofnative pncB Fed-batch 18.3 g/L [45]

K-12ppc Appc, expression of Actinobacillus succinogenes pck Batch 26.4mM [46]

Saccharomyces cerevisiae

AH22ura3 Asdh1, Asdh2, Aidh1, Aidp1 Batch 3.62 g/L, 0.11 mol/mol glucose [16]

DFRDS AOSM1, AFRDS Batch 130 ^mol/(h-g dry cells) [47]

8D Asdh, Aser3/ser33, Overexpression of native icl1 Batch 0.9 g/L [48]

Corynebacterium glutamicum

BL-1 Asdh, Apta-ackA, Apqo, Acat, overexpression of native ace, pyc and ppc Fed-batch 10.6 g/L, 0.45 mol/mol glucose [17]

BOL-2 Acat, Apqo, Apta-ackA, AldhA, overexpression of native pyc and Mycobacterium vaccae fdh Fed-batch 1134 mM, 1.67 mol/mol glucose [49]

Mannheimia succiniciproducens

LPK7 AldhA, ApflB, Apta, AackA Fed-batch 52.4 g/L, 1.16 mol/mol glucose [50]

succinate production to about 28.2 g/L, this strain lost its ability to ferment glucose anaerobically due to redox imbalance

[33]. The introduction of another null mutation of the ptsG gene which encoded a key enzyme for the PEP-dependent phosphotransferase system (PTS) essential to sugar uptake into the double mutant strain restored the ability to ferment glucose and the resulting strains produced more succinate

[34]. Fed-batch culture using the triple mutant strain as the host achieved a final succinate concentration of 99.2 g/l with an overall yield of 110% and productivity of 1.3 g/(L • h) [53]. In addition, pyruvate formation could be inhibited by disrupting two pyruvate kinases (pykF and pykA) together with the ptsG gene, which also allowedenhancedsuccinate production

For aerobic succinate production, the TCA cycle can be blocked at key points for the accumulation of succinate. The disruption of the sdh and icd genes is indispensable to create an aerobic succinate-producing strain [36]. The glyoxylate route, whichiscriticalfor aerobicsuccinate production, could be activated by knocking out a repressor protein, IclR [37]. Besides, pyruvate oxidase (pox), catalyzing the oxidation of pyruvate, leads to the production of acetate under aerobic conditions. Knockout of this gene was also shown to be helpful for the production of succinate and succinate yield reached 1.2 moles per moles of glucose [38].

5.2. Redirecting Metabolic Flux to the Intermediates ofSucci-nate-Producing Pathway. Overexpression of the genes directly involved in the succinate biosynthesis pathway also shows the potential to enhance its production. The genes coding for key enzymes responsible for succinate biosynthesis have been identified to be ppc, pck, pyc, mae, mdh, fum, and frd. There are three different kinds of CO2-fixing metabolic reactions catalyzed by ppc, pck, and pyc, respectively. These carboxylation reactions of three-carbon metabolites are the first step for succinate synthesis. Expression of these three key enzymes has been demonstrated to be critical for the enhancement of succinate production in different hosts [28, 39, 40, 50]. Mae, catalyzing the reductive carboxylation of pyruvate to malate, provides an alternative route to succinate from pyruvate instead of PEP. When expressing an NAD+-dependent malic enzyme in a mutant E. coli strain that was unable to metabolize pyruvate, fermentative metabolism was redirected to succinate and thus resulting in accumulation of succinate [41]. Mdh catalyzes the conversion of oxaloacetate to malate. Overexpressed mdh in the ldh and pfl double mutant strain could restore anaerobic cell growth and glucose utilization. About 21 g/L of glucose was completely consumed and succinate reached 15.2 g/L after anaerobic fermentation for 15 h [42]. Fum could convert malate to fumarate and further overexpression of this enzyme with mae eliminated malate production while enhancing succinate production [43]. Frd catalyzes the reduction of fumarate to succinate, the last step for succinate production. It plays a key role in the energy metabolism and also contributes to succinate production during microbial fermentation [54].

5.3. Enhancement of Reducing Power Availability and Energy Metabolism. When manipulating metabolic fluxes to specific

metabolites, it is important to achieve a redox and energy balance between the substrates and the products. Succinate biosynthesis is strongly determined by the reducing power and energy supplies of the host. The anaerobic fermentative pathway from PEP or pyruvate to succinate requires two moles of NADH [55]. The reducing power generated in the formation of PEP or pyruvate through the glycolytic pathway (one NADH) is not enough to convert all the PEP to succinate. Therefore, supplying additional reducing power has the potential to enhance succinate production

[56]. A higher NADH/NAD+ ratio could be obtained through manipulating the culture to a more reductive environment

[57]. By eliminating the IclR transcriptional repressor to activate the aerobic glyoxylate pathway in a mutant strain, enough NADH is generated to reduce the metabolic intermediates to succinate. This engineered strain was capable of achieving a succinate yield of 1.6 moles per mole of glucose at very high rates [44]. On the contrary, excessive supply of NADH might also inhibit succinate production. It is crucially important to maintain a redox balance in the host. For instance, NAD+ regeneration was achieved in the pfl and ldh double mutant strain by overexpression of nicotinate phosphoribosyltransferase. A significant increase in cell mass and succinate production were observed. The final titer was enhanced to 3.7-fold of the control strain under the same induction conditions [45].

ATP supply is another critical factor that influences the production of succinate. The conversion of PEP to oxaloacetate can be catalyzed by ppc and pck, respectively. Energy contained in PEP is lost using the former carboxylase with the release of inorganic phosphate. On the contrary, the reaction catalyzed by the ATP-generating pck, which was found in A. succiniciproducens [58], is favorable for succinate biosynthesis. Heterologous expressing this carboxykinase in an E. coli ppc mutant strain produced additional ATP and increased succinate production by 6.5-fold [46].

6. Fermentation Process Engineering

Fermentation engineering is the foundation for the industrialization of biobased succinate. The succinate fermentation process has been investigated in depth in the past few decades and recent work mainly focused on the following issues.

6.1. Optimization of Fermentation Conditions. Media components and fermentation process parameters are the most basic and simplest approach to achieve a higher titer of the desired products. Since the media for succinate fermentation always contains a variety of nutrient components, the effects of an individual component and the interactions between different components are needed to be studied, which requires rational experiment design. Plackett-Burman design (PBD) and central composite design (CCD) could be used for rapid screening of multifactors to find the most significant factors. Moreover, response surface methodology (RSM) was employed to optimize the concentration of the important factors. Succinate production of C. glutamicum in the optimized medium was about 1.46-fold higher than the original medium [59].

Other fermentation parameters such as CO2 (or carbonate) supply, temperature, pH, and dissolved oxygen (DO) also showed significant effect on succinate production. As one mole of CO2 is theoretically required for the synthesis of one mole of succinate, optimization of CO2 partial pressures would contribute to succinate production. Under the optimized conditions, a succinate concentration of 51.6 g/L with a yield of 75.8% was reached for the producer A. succinogenes [60]. The culture temperature should be optimized according to the strain employed. As the accumulation of succinate would make the culture broth to be acidic, the pH of the fermentation broth should be adjusted to a suitable value according to maximizing the production. A pH of 6.4 yielded the highest specific succinate productivity for E. coli strain AFP111 [61]. The DO control in the whole fermentation process also strongly affected cell growth and succinate production, especially for aerobic cultivation. It was found that 2-5 h of low dissolved oxygen culture during the aerobic phase improved succinate productivity using the metaboli-cally engineered E. coli strain SBS550MG [62].

6.2. Employment of Different Fermentation Strategies. Most of the current succinate-producing systems are performed under anaerobic conditions. Unfortunately, anaerobic fermentation has inherent disadvantages, for example, long doubling time, slow carbon throughput, and low product formation rates, that are difficult to surmount [63]. Therefore, a "dual-phase" fermentation process was established to overcome these problems. Cells grew quickly to generate enough biomass under aerobic conditions, then switching to anaerobic conditions for succinate production. The volumetric productivity of succinate was greatly enhanced for both E. coli NZN111 and AFP111 using the dual-phase culture strategy [64].

Batch or fed-batch fermentation is the preferred mode of operation for succinate production. However, continuous production of succinate is likely to outperform batch processing, especially when considering the projections of the following downstream processing. During the past few years, continuous succinate fermentation has been carried out by researchers from different institutes, but only the natural producers such as M. succiniciproducens [65], A. succiniciproducens [66], and A. succinogenes [67] have been tested. Cell recycle bioreactors with integrated membrane separation system are required for continuous succinate production.

6.3. Extension of the Fermentation Feedstocks. Glucose is generally used as the carbon source for succinate fermentation. Even though glucose is abundantly available, its relative high price increases the production costs. In addition, glucose is manufactured by hydrolyzing starch using a-amylase and debranching enzyme or isoamylase. The excessive consumption of glucose is a threat to global food security. In order to develop a more sustainable biobased industrial production of succinate, it will be crucial to use low-cost substrates, especially nonfood feedstocks, and develop a robust strain capable of catalyzing these raw materials to produce succinate in good yields.

Glycerol is an abundant waste product of the biodiesel industry with limited commercial uses. The biological production of succinate from glycerol is an attractive process, since it produces a high added-value compound from this byproduct while decreasing environmental pollution. Efficient bioconversion of glycerol to succinate has been successfully achieved by using A. succiniciproducens [21], A. succinogenes [68], and metabolically engineered E. coli [69].

Xylose is a renewable sugar which can be derived from lignocellulosic biomass. Fermentation of xylose to succinate has been made possible by current available strains. Anaerobic fermentation of xylose using an engineered E. coli strain produced a final succinate concentration of 11.13 g/L [70]. However, using pure xylose for fermentation is obviously economically unfeasible. To further lower the production cost, utilization of biomass hydrolysates, the second-generation fermentation feedstocks, seems to be more significant. There has been an increasing trend towards the utilization of agricultural wastes or residues such as corn straw [71], wheat straw [72], corn stover [73], and sugarcane bagasse [74]for the production of succinate. As most of the succinate-producing strains could not ferment cellulosic biomass, a pretreatment step is required for the conversion of lignocellulosic materials to reducing sugars. The saccharification technology is essential to downstream fermentation [75].

7. Separation and Purification of Succinate from the Fermentation Broth

Recovery of succinate from the fermentation broth is the last step for biological succinate production. The separation and purification of succinate are estimated to make up more than 50% of the total costs in its microbial production [76]. To make fermentation-based succinate production competitive with petrochemical processes, the development of optimized producing strains and fermentation processes must be combined with cost-saving and energy-effective downstream processes to minimize the production costs.

As shown in Figure 3, the first downstream processing step of succinate purification is to separate microbial cells from the fermentation broth by centrifugation or filtration which is followed by ultrafiltration to eliminate proteins, polysaccharides, and other polymers from the supernatant. For the isolation of purified succinate, different strategies including crystallization, precipitation, extraction, electro-dialysis, membrane separation, chromatography, and in situ separation have been investigated. The comparison of different downstream processing strategies for succinate separation is presented in Table 3. The traditional succinate recovery method is based on precipitation and crystallization technology. During succinate fermentation, Ca(OH)2 can be used to control the fermentation pH and precipitate succinate. In this process, a large amount of CaSO4 was accumulated, which is commercially useless [77]. Under acidic conditions, the solubility of succinate is relatively low. Therefore, the classical crystallization method could be used for the separation of succinate [78]. However, the low recovery rate and purity of the final product requires recrystallization

Proteins/polysaccharides

Fermentation broth

In situ separation (Succinic acid solution V

( Ultrafiltrate )

Concentrated succinic acid

Crystallization

("Purified succinic acid )

Figure 3: Strategic approaches for the separation and purification of succinate from the fermentation broth.

Table 3: Comparison of different downstream processing strategies for succinate separation and purification.

Downstream processing strategies

Advantages

Disadvantages

Crystallization

Precipitation

Extraction

Electrodialysis

Chromatography

In situ separation

Easy to be operated; without additional reagents.

Low technological barriers; inexpensive precipitants.

High output and low energy consumption.

Relatively mild conditions; can be used for continuous separation.

Easy to be scaled up.

Can be coupled with the fermentation process; relieving product inhibition.

Low succinate yield and purity; recrystallization is required.

Requirement of large quantities of precipitants; generation of useless by-products.

Pretreatment of the fermentation broth is required; expensive extraction agents used for reactive extraction.

High energy consumption; high cost of the membranes; low selectivity for succinate.

Regeneration of the chromatographic matrix requires large amounts of acids and alkalis.

Relatively complicated processes; regeneration of separation sorbent is required.

to make the final product suitable for commercial use. Among different extraction methods, the reactive extraction of succinate using aliphatic amines as reactive components has been widely reported. The distribution coefficient of succinate in different phases could be easily controlled via adjusting the pH value of the fermentation broth. About 99.8% of purity and 73.1% of recovery rate could be obtained through a newly developed reactive extraction process [79]. However, most of the studies on reactive extraction were performed with pure aqueous phases and the process is often interfered by contaminated acids, impurities, carbon sources, protein, or salts. Electrodialysis is another process capable of separating succinate from nonionized compounds and can be combined with continuous fermentation to realize in situ recovery of succinate [80]. The main drawback of this process is its high energy consumption and the expensive and easily polluted membranes. The chromatography methods, especially using ion exchange or adsorption resin, have been recently reported in many studies [81]. An adsorbent resin NERCB09 was found to have a high adsorption capacity of succinate with an excellent recycling property [82]. The same as many other chromatographic processes, the resin used has to be regenerated frequently and the regeneration of sorbent needs a large quantity of acid and alkali, resulting

in additional pollutions. As high concentration of succinate would inhibit cell growth, removing the inhibitory product directly from the ongoing fermentation broth might enhance its production. The strategies of extraction, electrodialysis, and chromatographic absorption have the potential to be used for in situ separation. In situ product removal always requires a specific integrated fermentation system [83]. The requirement of specific bioreactor increases the production costs.

Up to now, separation and purification of succinate from the fermentation broth is still an economical obstacle for its biological production. The downstream processing methods employed by BioAmber for commercial production were mainly based on the classical crystallization strategy [84]. No commercial applications have been reported using the other recovery techniques discussed above since the separation methods studied so far have some drawbacks or limitations. The key challenge to successfully separate succinate from the fermentation broth is how to apply these downstream processing technologies to large-scale industrial processes in a cost- and time-effective manner. In addition, separation process coupled with upstream fermentation, that is, in situ product removal, deserves more attentions in the future.

8. Conclusions and Future Perspectives

Succinate is finding increasing applications in various areas and biological succinate manufacturing represents a promising path for its viable industrial production. Fermentative succinate production has many advantages, for example, the decreasing consumption of nonrenewable resources and the reduction of greenhouse gas emissions [85]. With the efforts of many researchers in different fields, the current production cost of biobased succinate has been economically competitive with traditional petrochemical processes. However, the extension of biobased succinate as an intermediary feedstock for bulk chemicals production will still rely on inexpensive manufacturing processes. It is estimated that the total production cost of succinate could drop to below $0.45/kg under the perfect condition [86]. The current biological process is still far from this expectation.

The production cost of biobased succinate is largely decided by two factors: the fermentation process and the separation process. As discussed above, downstream processing makes up the majority cost for succinate production. Therefore, downstream processing ranks at the first place to achieve an industrial level production. The development of economically competitive separation technology is essential to reduce the production cost. On the other hand, the quality of the fermentation process will determine the difficulty of separating. The titer of succinate and the content of other organic acids in the fermentation broth strongly affect the separation process. Microbial strains with improved succinate-producing ability and lower by-products formation allow for simpler and less expensive purification methods. Recent advances in synthetic biology and systems biology have provided new tools to construct more efficient succinate-producing strains [87]. In addition, improvements of the fermentation process and its integration with the separation system also have the potential to lower the whole production cost. It must be admitted that advances in biobased succinate production could only be achieved under the cooperation of scientists having different background and expertise.

Obviously, fermentative succinate production opens a new direction for bulk chemicals manufacture. Although a number of technical challenges must be overcome, the development of this biological process has a long term prospect. We believe that by the joint efforts of researchers in different fields, a sustainable and economically attractive biobased succinate production will finally replace the traditional petrochemical processes in the near future.

Acknowledgments

This work was supported by the National Natural Science Foundation of China (nos. 21202179 and 21206185), the Sci-Tech Development Project of Qingdao (no. 12-1-4-9-(3)-jch), and the Key Technologies Research and Development Program of China (No. 2012BAD32B06).

References

[1] D. K. Dougall and K. W. Weyrauch, "Abilities of organic acids to

support growth and anthocyanin accumulation by suspension

cultures of wild carrot cells using ammonium as the sole nitrogen source," In Vitro, vol. 16, no. 11, pp. 969-975,1980.

[2] F. Chimirri, F. Bosco, R. Ceccarelli, A. Venturello, and F. Geo-baldo, "Succinic acid and its derivatives: fermentative production using sustainable industrial agro-food by-products and its applications in the food industry," Italian Journal of Food Science, vol. 22, no. 2, pp. 119-125, 2010.

[3] A. Sener, M. M. Kadiata, L. Ladrière, and W. J. Malaisse, "Synergistic insulinotropic action of succinate, acetate, and glucose esters in islets from normal and diabetic rats," Endocrine, vol. 7, no. 2, pp. 151-155,1997.

[4] C. Yu, Y. Cao, H. Zou, and M. Xian, "Metabolic engineering of Escherichia coli for biotechnological production of high-value organic acids and alcohols," Applied Microbiology and Biotechnology, vol. 89, no. 3, pp. 573-583, 2011.

[5] J. Xu and B.-H. Guo, "Poly (butylene succinate) and its copolymers: research, development and industrialization," Biotechnology Journal, vol. 5, no. 11, pp. 1149-1163, 2010.

[6] L. Nattrass, M. Aylott, and A. Higson, NNFCC Renewable Chemicals Factsheet: Succinic Acid, NNFCC, 2013.

[7] MarketsandMarkets, Succinic Acid Market by Applications & Geography—Global Trends & Forecasts (2011-2016), 2012.

[8] O. L. Polly, "Production of succinic acid," United States patent 2533620, 1950.

[9] S. M. Jung, E. Godard, S. Y. Jung, K.-C. Park, and J. U. Choi, "Liquid-phase hydrogenation of maleic anhydride over Pd-Sn/SiO2," Catalysis Today, vol. 87, no. 1-4, pp. 171-177, 2003.

[10] T. Hu, H. Yin, R. Zhang, H. Wu, T. Jiang, and Y. Wada, "Gas phase hydrogenation of maleic anhydride to y-butyrolactone by Cu-Zn-Ti catalysts," Catalysis Communications, vol. 8, no. 2, pp. 193-199, 2007.

[11] A. V. Muzumdar, S. B. Sawant, and V. G. Pangarkar, "Reduction of maleic acid to succinic acid on titanium cathode," Organic Process Research and Development, vol. 8, no. 4, pp. 685-688, 2004.

[12] J. F. Vitcha and W. Lester, "Preparation of succinic acid," United States Patent 3341578,1967.

[13] T. Werpy and G. Petersen, Top Value Added Chemicals from Biomass. Volume 1: Results of Screening for Potential Candidates from Sugars and Synthesis Gas, U.S. Department of Energy, 2004.

[14] H. Song and S. Y. Lee, "Production of succinic acid by bacterial fermentation," Enzyme and Microbial Technology, vol. 39, no. 3, pp. 352-361, 2006.

[15] H. Lin, G. N. Bennett, and K.-Y. San, "Genetic reconstruction of the aerobic central metabolism in Escherichia coli for the absolute aerobic production of succinate," Biotechnology and Bioengineering, vol. 89, no. 2, pp. 148-156, 2005.

[16] A. M. Raab, G. Gebhardt, N. Bolotina, D. Weuster-Botz, and C. Lang, "Metabolic engineering of Saccharomyces cerevisiae for the biotechnological production of succinic acid," Metabolic Engineering, vol. 12, no. 6, pp. 518-525, 2010.

[17] B. Litsanov, A. Kabus, M. Brocker, and M. Bott, "Efficient aerobic succinate production from glucose in minimal medium with Corynebacterium glutamicum," Microbial Biotechnology, vol. 5, no. 1, pp. 116-128, 2012.

[18] S. Meijer, J. Otero, R. Olivares, M. R. Andersen, L. Olsson, and J. Nielsen, "Overexpression of isocitrate lyase-glyoxylate bypass influence on metabolism in Aspergillus niger," Metabolic Engineering, vol. 11, no. 2, pp. 107-116, 2009.

[19] K. Chen, M. Jiang, P. Wei, J. Yao, and H. Wu, "Succinic acid production from acid hydrolysate of corn fiber by Actinobacillus succinogenes," Applied Biochemistry and Biotechnology, vol. 160, no. 2, pp. 477-485, 2010.

[20] H. Song, S. H. Jang, J. M. Park, and S. Y. Lee, "Modeling of batch fermentation kinetics for succinic acid production by Mannheimia succiniciproducens," Biochemical Engineering Journal, vol. 40, no. 1, pp. 107-115, 2008.

[21] P. C. Lee, W. G. Lee, S. Y. Lee, and H. N. Chang, "Succinic acid production with reduced by-product formation in the fermentation of Anaerobiospirillum succiniciproducens using glycerol as a carbon source," Biotechnology and Bioengineering, vol. 72, no. 1, pp. 41-48, 2001.

[22] E. T. M. Ling, J. T. Dibble, and M. R. Houston, "Accumulation of 1-trans-2,3-epoxysuccinic acid and succinic acid by Paecilomyces varioti," Applied and Environmental Microbiology, vol. 35, no. 6, pp. 1213-1215, 1978.

[23] A. Bercovitz, Y. Peleg, E. Battat, J. S. Rokem, and I. Goldberg, "Localization of pyruvate carboxylase in organic acid-producing Aspergillus strains," Applied and Environmental Microbiology, vol. 56, no. 6, pp. 1594-1597,1990.

[24] M. Gallmetzer, J. Meraner, and W. Burgstaller, "Succinate synthesis and excretion by Penicillium simplicissimum under aerobic and anaerobic conditions," FEMS Microbiology Letters, vol. 210, no. 2, pp. 221-225, 2002.

[25] V. Coustou, S. Besteiro, L. Riviere et al., "A mitochondrial NADH-dependent fumarate reductase involved in the production of succinate excreted by procyclic Trypanosoma brucei," Journal of Biological Chemistry, vol. 280, no. 17, pp. 16559-16570, 2005.

[26] F. Yang and Y. Cao, "Biosynthesis of phloroglucinol compounds in microorganisms—review," Applied Microbiology and Biotechnology, vol. 93, no. 2, pp. 487-495, 2012.

[27] Y. Cao, Y. Cao, and M. a. Zhao, "Biotechnological production of eicosapentaenoic acid: from a metabolic engineering point of view," Process Biochemistry, vol. 47, no. 9, pp. 1320-1326, 2012.

[28] S. Okino, R. Noburyu, M. Suda, T. Jojima, M. Inui, and H. Yukawa, "An efficient succinic acid production process in a metabolically engineered Corynebacterium glutamicum strain," Applied Microbiology and Biotechnology, vol. 81, no. 3, pp. 459464, 2008.

[29] Y. Wakai, T. Shimazaki, and S. Hara, "Formation of succinate during fermentation of sake mash and grape must," Hakkoko-gaku Kaishi-Journal of the Society of Fermentation Technology, vol. 58, no. 5, pp. 363-368, 1980.

[30] L. Sun, H. Zhang, H. Yuan, R. Tu, Q. Wang, and Y. Ma, "A double-enzyme-coupled assay for high-throughput screening of succinic acid-producing strains," Journal of Applied Microbiology, vol. 114, no. 6, pp. 1696-1701, 2013.

[31] K. K. Cheng, G. Y. Wang, J. Zeng, and J. A. Zhang, "Improved succinate production by metabolic engineering," Biomed Research International, vol. 2013, Article ID 538790, 12 pages, 2013.

[32] A. M. Sanchez, G. N. Bennett, and K.-Y. San, "Efficient succinic acid production from glucose through overexpression of pyru-vate carboxylase in an Escherichia coli alcohol dehydrogenase and lactate dehydrogenase mutant," Biotechnology Progress, vol. 21, no. 2, pp. 358-365, 2005.

[33] H. Wu, Z.-M. Li, L. Zhou, and Q. Ye, "Improved succinic acid production in the anaerobic culture of an Escherichia coli pflB ldhA double mutant as a result of enhanced anaplerotic

activities in the preceding aerobic culture," Applied and Environmental Microbiology, vol. 73, no. 24, pp. 7837-7843, 2007.

[34] R. Chatterjee, C. S. Millard, K. Champion, D. P. Clark, and M. I. Donnelly, "Mutation of the ptsG gene results in increased production of succinate in fermentation of glucose by Escherichia coli" Applied and Environmental Microbiology, vol. 67, no. 1, pp. 148-154, 2001.

[35] S. J. Lee, D.-Y. Lee, T. Y. Kim, B. H. Kim, J. Lee, and S. Y. Lee, "Metabolic engineering of Escherichia coli for enhanced production of succinic acid, based on genome comparison and in silico gene knockout simulation," Applied and Environmental Microbiology, vol. 71, no. 12, pp. 7880-7887, 2005.

[36] Z. Liu, X. Wang, Q. Qi, and Q. Hua, "Quantification and analysis of metabolic characteristics of aerobic succinate-producing Escherichia coli under different aeration conditions," Process Biochemistry, vol. 47, no. 11, pp. 1532-1538, 2012.

[37] H. Lin, G. N. Bennett, and K.-Y. San, "Chemostat culture characterization of Escherichia coli mutant strains metabolically engineered for aerobic succinate production: a study of the modified metabolic network based on metabolite profile, enzyme activity, and gene expression profile," Metabolic Engineering, vol. 7, no. 5-6, pp. 337-352, 2005.

[38] K. Jantama, X. Zhang, J. C. Moore, K. T. Shanmugam, S. A. Svoronos, and L. O. Ingram, "Eliminating side products and increasing succinate yields in engineered strains of Escherichia coli C," Biotechnology and Bioengineering, vol. 101, no. 5, pp. 881893, 2008.

[39] C. S. Millard, Y.-P. Chao, J. C. Liao, and M. I. Donnelly, "Enhanced production of succinic acid by overexpression of phosphoenolpyruvate carboxylase in Escherichia coli" Applied and Environmental Microbiology, vol. 62, no. 5, pp. 1808-1810, 1996.

[40] X. Zhang, K. Jantama, J. C. Moore, L. R. Jarboe, K. T. Shan-mugam, and L. O. Ingram, "Metabolic evolution of energy-conserving pathways for succinate production in Escherichia coli" Proceedings of the National Academy of Sciences of the United States of America, vol. 106, no. 48, pp. 20180-20185,2009.

[41] L. Stols and M. I. Donnelly, "Production of succinic acid through overexpression of NAD+-dependent malic enzyme in an Escherichia coli mutant," Applied and Environmental Microbiology, vol. 63, no. 7, pp. 2695-2701,1997.

[42] L.-Y. Liang, R.-M. Liu, J.-F. Ma, K.-Q. Chen, M. Jiang, and P. Wei, "Increased production of succinic acid in Escherichia coli by overexpression of malate dehydrogenase," Biotechnology Letters, vol. 33, no. 12, pp. 2439-2444, 2011.

[43] S. H. Hong and S. Y. Lee, "Enhanced production of succinic acid by metabolically engineered Escherichia coli with amplified activities of malic enzyme and fumarase," Biotechnology and Bioprocess Engineering, vol. 9, no. 4, pp. 252-255, 2004.

[44] A. M. Sanchez, G. N. Bennett, and K.-Y. San, "Batch culture characterization and metabolic flux analysis of succinate-producing Escherichia coli strains," Metabolic Engineering, vol. 8, no. 3, pp. 209-226, 2006.

[45] L. Liang, R. Liu, G. Wang et al., "Regulation of NAD(H) pool and NADH/NAD+ ratio by overexpression of nicotinic acid phosphoribosyltransferase for succinic acid production in Escherichia coli NZN111," Enzyme and Microbial Technology, vol. 51, no. 5, pp. 286-293, 2012.

[46] P. Kim, M. Laivenieks, C. Vieille, and J. G. Zeikus, "Effect of overexpression of Actinobacillus succinogenes phosphoe-nolpyruvate carboxykinase on succinate production in

Escherichia coli" Applied and Environmental Microbiology, vol. 70, no. 2, pp. 1238-1241, 2004.

[47] Y. Arikawa, T. Kuroyanagi, M. Shimosaka et al., "Effect of gene disruptions of the TCA cycle on production of succinic acid in Saccharomyces cerevisiae" Journal of Bioscience and Bioengineering, vol. 87, no. 1, pp. 28-36,1999.

[48] J. M. Otero, D. Cimini, K. R. Patil, S. G. Poulsen, L. Olsson, and J. Nielsen, "Industrial systems biology of Saccharomyces cerevisiae enables novel succinic acid cell factory," PLoS ONE, vol. 8, no. 1, Article ID e54144, 2013.

[49] B. Litsanov, M. Brocker, and M. Bott, "Toward homosuccinate fermentation: metabolic engineering of Corynebacterium glu-tamicum for anaerobic production of succinate from glucose and formate," Applied and Environmental Microbiology, vol. 78, no. 9, pp. 3325-3337, 2012.

[50] S. J. Lee, H. Song, and S. Y. Lee, "Genome-based metabolic engineering of Mannheimia succiniproducens for succinic acid production," Applied and Environmental Microbiology, vol. 72, no. 3, pp. 1939-1948, 2006.

[51] Y. Cao, Y. Cao, and X. Lin, "Metabolically engineered Escherichia coli for biotechnological production of four-carbon 1,4-dicarboxylic acids," Journal of Industrial Microbiology and Biotechnology, vol. 38, no. 6, pp. 649-656, 2011.

[52] J. Zhu and K. Shimizu, "The effect of pfl gene knockout on the metabolism for optically pure D-lactate production by Escherichia coli" Applied Microbiology and Biotechnology, vol. 64, no. 3, pp. 367-375, 2004.

[53] G. N. Vemuri, M. A. Eiteman, and E. Altman, "Succinate production in dual-phase Escherichia coli fermentations depends on the time of transition from aerobic to anaerobic conditions," Journal of Industrial Microbiology and Biotechnology, vol. 28, no. 6, pp. 325-332, 2002.

[54] S. Besteiro, M. Biran, N. Biteau et al., "Succinate secreted by Trypanosoma brucei is produced by a novel and unique glycosomal enzyme, NADH-dependent fumarate reductase," Journal ofBiological Chemistry, vol. 277, no. 41, pp. 38001-38012, 2002.

[55] H. Lin, G. N. Bennett, and K.-Y. San, "Effect of carbon sources differing in oxidation state and transport route on succinate production in metabolically engineered Escherichia coli" Journal of Industrial Microbiology and Biotechnology, vol. 32, no. 3, pp. 87-93, 2005.

[56] S. H. Hong and S. Y. Lee, "Importance of redox balance on the production of succinic acid by metabolically engineered Escherichia coli" Applied Microbiology and Biotechnology, vol. 58, no. 3, pp. 286-290, 2002.

[57] X. Chen, S. Jiang, Z. Zheng, L. Pan, and S. Luo, "Effects of culture redox potential on succinic acid production by Corynebacterium crenatum under anaerobic conditions," Process Biochemistry, vol. 47, no. 8, pp. 1250-1255, 2012.

[58] M. Laivenieks, C. Vieille, and J. G. Zeikus, "Cloning, sequencing, and overexpression of the Anaerobiospirillum succinicipro-ducens phosphoenolpyruvate carboxykinase (pckA) gene," Applied and Environmental Microbiology, vol. 63, no. 6, pp. 2273-2280,1997.

[59] J. M. Jeon, R. Thangamani, E. Song, H. W. Lee, H. W. Lee, and Y. H. Yang, "Media optimization of Corynebacterium glutamicum for succinate production under oxygen-deprived condition," Journal of Microbiology and Biotechnology, vol. 23, no. 2, pp. 211217, 2013.

[60] Y.-L. Xi, K.-Q. Chen, J. Li et al., "Optimization of culture conditions in CO2 fixation for succinic acid production using

Actinobacillus succinogenes" Journal of Industrial Microbiology and Biotechnology, vol. 38, no. 9, pp. 1605-1612, 2011.

[61] S. Lu, M. A. Eiteman, and E. Altman, "PH and base counterion affect succinate production in dual-phase Escherichia coli fermentations," Journal of Industrial Microbiology and Biotechnology, vol. 36, no. 8, pp. 1101-1109, 2009.

[62] J. Zhu, C. Thakker, K.-Y. San, and G. Bennett, "Effect of culture operating conditions on succinate production in a multiphase fed-batch bioreactor using an engineered Escherichia coli strain," Applied Microbiology and Biotechnology, vol. 92, no. 3, pp. 499-508, 2011.

[63] H. Lin, G. N. Bennett, and K.-Y. San, "Fed-batch culture of a metabolically engineered Escherichia coli strain designed for high-level succinate production and yield under aerobic conditions," Biotechnology and Bioengineering, vol. 90, no. 6, pp. 775-779, 2005.

[64] G. N. Vemuri, M. A. Eiteman, and E. Altman, "Effects of growth mode and pyruvate carboxylase on succinic acid production by metabolically engineered strains of Escherichia coli" Applied and Environmental Microbiology, vol. 68, no. 4, pp. 1715-1727, 2002.

[65] D. Y. Kim, S. C. Yim, P. C. Lee, W. G. Lee, S. Y. Lee, and H. N. Chang, "Batch and continuous fermentation of succinic acid from wood hydrolysate by Mannheimia succiniciproducens MBEL55E," Enzyme and Microbial Technology, vol. 35, no. 6-7, pp. 648-653, 2004.

[66] P. C. Lee, S. Y. Lee, and H. N. Chang, "Kinetic study on succinic acid and acetic acid formation during continuous cultures of Anaerobiospirillum succiniciproducens grown on glycerol," Bioprocess and Biosystems Engineering, vol. 33, no. 4, pp. 465471, 2010.

[67] C. D. van Heerden and W. Nicol, "Continuous succinic acid fermentation by Actinobacillus succinogenes" Biochemical Engineering Journal, vol. 73, pp. 5-11, 2013.

[68] M. de Barros, S. Freitas, G. Padilha, and R. Alegre, "Biotechnological production of succinic acid by Actinobacillus succinogenes using different substrate," Chemical Engineering Transactions, vol. 32, pp. 985-990, 2013.

[69] X. Zhang, K. T. Shanmugam, and L. O. Ingram, "Fermentation of glycerol to succinate by metabolically engineered strains of Escherichia coli" Applied and Environmental Microbiology, vol. 76, no. 8, pp. 2397-2401, 2010.

[70] R. Liu, L. Liang, K. Chen et al., "Fermentation of xylose to succinate by enhancement of ATP supply in metabolically engineered Escherichia coli" Applied Microbiology and Biotechnology, vol. 94, no. 4, pp. 959-968, 2012.

[71] X. Li, Z. Zheng, Z. Wei, S. Jiang, L. Pan, and S. Weng, "Screening, breeding and metabolic modulating of a strain producing succinic acid with corn straw hydrolyte," World Journal of Microbiology and Biotechnology, vol. 25, no. 4, pp. 667-677,

[72] Q. Li, J. A. Siles, and I. P. Thompson, "Succinic acid production from orange peel and wheat straw by batch fermentations of Fibrobacter succinogenes S85," Applied Microbiology and Biotechnology, vol. 88, no. 3, pp. 671-678, 2010.

[73] P. Zheng, L. Fang, Y. Xu, J.-J. Dong, Y. Ni, and Z.-H. Sun, "Succinic acid production from corn stover by simultaneous saccharification and fermentation using Actinobacillus succinogenes" Bioresource Technology, vol. 101, no. 20, pp. 7889-7894,

[74] E. R. Borges and N. Pereira Jr., "Succinic acid production from sugarcane bagasse hemicellulose hydrolysate by Actinobacillus

succinogenes," Journal of Industrial Microbiology and Biotechnology, vol. 38, no. 8, pp. 1001-1011, 2011.

[75] Q. Li, Y.-C. He, M. Xian et al., "Improving enzymatic hydrolysis of wheat straw using ionic liquid 1-ethyl-3-methyl imidazolium diethyl phosphate pretreatment," Bioresource Technology, vol. 100, no. 14, pp. 3570-3575, 2009.

[76] K. K. Cheng, X. B. Zhao, J. Zeng et al., "Downstream processing of biotechnological produced succinic acid," Applied Microbiology and Biotechnology, vol. 95, no. 4, pp. 841-850, 2012.

[77] J. B. McKinlay, C. Vieille, and J. G. Zeikus, "Prospects for a bio-based succinate industry," Applied Microbiology and Biotechnology, vol. 76, no. 4, pp. 727-740, 2007.

[78] Q. Li, D. Wang, Y. Wu et al., "One step recovery of succinic acid from fermentation broths by crystallization," Separation and Purification Technology, vol. 72, no. 3, pp. 294-300, 2010.

[79] Y. S. Huh, Y.-S. Jun, Y. K. Hong, H. Song, S. Y. Lee, and W. H. Hong, "Effective purification of succinic acid from fermentation broth produced by Mannheimia succiniciproducens," Process Biochemistry, vol. 41, no. 6, pp. 1461-1465, 2006.

[80] D. A. Glassner, P. Elankovan, D. R. Beacom, and K. A. Berglund, "Purification process for succinic acid produced by fermentation," Applied Biochemistry and Biotechnology, vol. 51-52, no. 1, pp. 73-82,1995.

[81] H.-G. Nam, K.-M. Park, S. S. Lim, and S. Mun, "Adsorption equilibria of succinic acid and lactic acid on amberchrom CG300C resin," Journal of Chemical and Engineering Data, vol. 56, no. 3, pp. 464-471, 2011.

[82] Q. Li, J. Xing, W. Li, Q. Liu, and Z. Su, "Separation of suc-cinic acid from fermentation broth using weak alkaline anion exchange adsorbents," Industrial and Engineering Chemistry Research, vol. 48, no. 7, pp. 3595-3599, 2009.

[83] A. J. Hepburn and A. J. Daugulis, "The use of CO2 for reversible pH shifting, and the removal of succinic acid in a polymer-based two-phase partitioning bioreactor," Journal of Chemical Technology and Biotechnology, vol. 87, no. 1, pp. 42-50, 2012.

[84] O. S. Fruchey, B. T. Keen, B. A. Albin, N. A. Clinton, D. Dunuwila, and B. D. Dombek, "Processes for producing suc-cinic acid from fermentation broths containing diammonium succinate," United States patent 20110297527, 2011.

[85] K.-K. Cheng, X.-B. Zhao, J. Zeng, and J.-A. Zhang, "Biotechnological production of succinic acid: current state and perspectives," Biofuels, Bioproducts and Biorefining, vol. 6, no. 3, pp. 302-318, 2012.

[86] J. J. Beauprez, M. De Mey, and W. K. Soetaert, "Microbial succinic acid production: natural versus metabolic engineered producers," Process Biochemistry, vol. 45, no. 7, pp. 1103-1114, 2010.

[87] L. R. Jarboe, X. L. Zhang, X. Wang, J. C. Moore, K. T. Shan-mugam, and L. O. Ingram, "Metabolic engineering for production of biorenewable fuels and chemicals: contributions of synthetic biology," Journal of Biomedicine and Biotechnology, vol. 2010, Article ID 761042,18 pages, 2010.

Copyright of BioMed Research International is the property of Hindawi Publishing Corporation and its content may not be copied or emailed to multiple sites or posted to a listserv without the copyright holder's express written permission. However, users may print, download, or email articles for individual use.